Mr. Heater MH125KTFR, Инструкция по эксплуатации и руководство пользователя

Страница: 5 / 27

Mr. Heater, Inc. | Kerosene Fired Radiant Heater Operating Instructions and Owner’s Manual
5
DIAGNOSTIC SAFETY SHUTDOWN AND TROUBLE SHOOTING
FAULT CAUSE SOLUTION
Motor­does­not­start­and­no­ignition
No­electrical­current
Check­power­supply­(is­it­plugged­in?)
Check­proper­position­of­the­switch­(is­it­on?)
Check­fuse/breaker
Wrong­setting­on­thermostat Check­for­setting­of­thermostat­higher­than­room­
temp.
Defective­motor Replace­Motor
Motor­starts­no­ignition­or­cuts­out
Not­enough­fuel­at­the­burner
Ensure­an­adequate­level­of­fuel­is­in­the­tank.
Cycle­unit­a­few­time­to­allow­fuel­to­fill­the­filter­
and­fuel­system.­
Check­fuel­lines­including­filter­for­leaks.
Clean­or­replace­nozzle.
Electronic­igniter­defective
Check­igniter­connections­including­transformer
Check­electrodes­for­corrosion­and­carbon­build­up.
Replace­transformer
Flame­control­box­defective Replace­flame­control­box
Photocell­defective Clean­or­replace­photo­cell
Solenoid­defective
Check­connections
Replace­solenoid
Motor­starts,­heater­emits­smoke
Not­enough­combustion­air
Make­sure­Air­inlet­and­outlet­are­free
Clean­burner­disc
Fuel­contaminated­or­contains­water
Drain­fuel­in­tank­and­replace­with­clean­fuel
Clean­or­replace­fuel­filter
Air­leaks­in­fuel­circuit Check­fuel­lines­and­system­for­possible­leaks
Not­enough­fuel­at­burner Clean­or­replace­fuel­nozzle
Too­much­fuel­at­burner Replace­nozzle
Heater­does­not­stop Solenoid­defective Replace­solenoid
LED DIAGNOSTIC READ OUT TABLE
ERROR CODE DESCRIPTION
E1 Ignition­failed­or­flame­out
E2 Temperature­sensor­malfunction
E3 High­limit­switch­over­heat
E4 Flame­control­malfunction
E5 Solenoid­monitor­malfunction
E6 Phot­cell­fault
E7 Motor­speed­fault
DEFAULT T-STAT SETTING T-STAT RANGE
68°F 41°F­-­99°F