Mazda 626 MX-6, Руководство по ремонту

Страница: 4 / 1246

0 PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION TABLE
EXTERIOR
INSPECT and ADJUST, if necessary, the following items
to the specifications:
□ Glass, exterior bright metal and paint for damage
□ Wheel lug nuts
88—118 N m (9—12 m-kg, 65—87 ft-lb)
□ Tire pressures (Refer to section 12)
□ All weatherstrips for damage or detachment
□ Operation of hood release and lock
□ Operation of fuel lid and trunk lid (Back door) opener
□ Door operation and alignment
□ Headlight aiming
INSTALL following parts:
□ Wheel caps or rings (if equipped)
□ Outside rear view mirror(s)
UNDER HOOD—ENGINE OFF
INSPECT and ADJUST, if necessary, the following items
to the specifications:
□ Fuel, coolant and hydraulic lines, fittings, connections and
components for leaks
□ Engine oil level
□ Power steering fluid level (if equipped)
□ Brake and clutch master cylinder fluid level (if equipped)
□ Windshield washer reservoir fluid level
□ Radiator coolant level and specific gravity
Protection °C (°F) Specific gravity at 20°C (68°F)
- 4 (25) 1.028
-1 6 (3 ) 1.054
-2 6 (-15) 1.066
-4 0 (-40)
1.078
□ Tightness of water hose clamps (including heater hoses)
□ Tightness of battery terminals
□ Manual transaxle oil level
□ Drive belt tensions (Refer to section 1)
□ Accelerator cable and its linkage for free movement
□ Headlight cleaner fluid level (if equipped)
CLEAN spark plugs
INTERIOR
INSTALL the following parts:
□ Rubber stopper for inside rear view mirror
□ Fuse for accessories
CHECK the operations of the following items:
□ Seat controls (sliding and reclining) and head rest
□ Door locks including childproof door locks (if equipped)
□ Seat belts and warning system
□ Ignition switch and steering lock
□ Inhibitor switch (ATX only)
□ All lights including warning and indicator lights
□ Sound warning system
□ Headlight cleaner (if equipped)
□ Horn, wipers and washers (front and rear, if equipped)
□ Radio and antenna (if equipped)
□ Cigarette lighter and clock
□ Remote control outside rear view mirrors (if equipped)
□ Power windows (if equipped)
□ Heater, defroster and air conditioner at various mode
selection (if equipped)
□ Sunroof (if equipped)
ADJUST antenna trimmer on radio (if equipped)
CHECK the following items:
□ Presence of spare fuse
□ Upholstery and interior finish
CHECK and ADJUST, if necessary, the following items:
□ Operation and fit of windows
□ Pedal height and free play of brake and clutch pedal
Pedal height mm (in) free play m m (in)
C lutch pedal 216.5-217 (8.52-8.54)
5—13 (0.2-0 .51)
Brake pedal 222-227 (8.74-8.94) 4 - 7 (0.16-0.28)
□ Parking brake
5 -7 noches/98 N (10 kg, 22lb)
UNDER HOOD—ENGINE RUNNING AT
OPERATING TEMPERATURE__________
CHECK the following items:
□ Automatic transaxle fluid level
□ Initial ignition timing
Non-turbo 6° ± 1 ° BTDC
Turbo
9
° ±
1
° BTDC (with test connector grounded)
ON HOIST
CHECK the following items:
□ Underside fuel, coolant and hydraulic lines, fittings, con­
nections and components for leaks
□ Tires for cuts or bruises
□ Steering linkage, suspension, exhaust system and all un­
derside hardware for looseness or damage
REMOVE protective cover from brake discs
ROAD TEST^
CHECK the following items:
□ Brake operation
□ Clutch operation
□ Steering control
□ Operation of meters and gauge
□ Squeaks, rattles or unusual noise
□ Engine general performance (including turbo)
□ Emergency locking retractors
□ Cruise control system (if equipped)
AFTER ROAD TEST
REMOVE seat and floor mat protective covers
CHECK for necessary owner information materials, tools and
spare tire in vehicle
86U00X-002