Magnum MLT5060, Инструкция по эксплуатации и каталог запасных частей, Страница: 5 / 64

5
Internal combustion engines present special hazards during operation and fueling! Failure to follow the
safety guidelines described below could result in severe injury or death. Also read and follow all safety
warnings described in the Engine Operator's Manual. A copy of this manual was supplied with unit when
it was shipped from the factory.
• DO NOT run engine indoors or in an area with poor ventilation unless exhaust hoses are used. Diesel
engine exhaust contains carbon monoxide, a deadly, odorless and colorless gas which, if inhaled,
can cause nausea, fainting or death. Make sure engine exhaust cannot seep into closed rooms or
ventilation equipment.
• DO NOT fill fuel tank near an open flame, while smoking, or while engine is running. DO NOT fill tank
in an enclosed area with poor ventilation.
• DO NOT operate with the fuel tank cap loose or missing.
• DO NOT touch or lean against hot exhaust pipes or engine cylinders.
• DO NOT clean air filter with gasoline or other types of low flash point solvents.
• DO NOT remove engine coolant cap while engine is hot.
• Keep area around exhaust pipes and air ducts free of debris to reduce the chance of an accidental
fire.
• Prolonged exposure to sound levels in excess of 85 DBA can cause permanent hearing loss. Wear
hearing protection when working around a running engine.
DO NOT operate the unit without a
functional exhaust system.
• Batteries contain sulfuric acid which can cause severe injury or death. Sulfuric acid can cause eye
damage, burn flesh or eat holes in clothing. Protective eye wear and clothing are necessary when
working on or around the battery. Always disconnect the NEGATIVE (-) battery cable from the
corresponding terminal before performing any service on the engine or other components.
• Shut the engine down if any of the following conditions exist during operation:
1. Noticeable change in engine speed.
2. Loss of electrical output.
3. Equipment connected to the generator overheats.
4. Sparking occurs.
5. Engine misfires or there is excessive engine/generator vibration.
6. Operating on a combustible surface.
7. Protective covers are loose or missing.
8. If the ambient air temperature is above 110° F.
ENGINE SAFETY
This unit uses high voltage circuits capable of causing serious injury or death. Only a qualified electrician
should troubleshoot or repair electrical problems occurring in this equipment.
• Before servicing light tower, make sure the engine start switch is turned to OFF, circuit breakers are
open (off) and the negative terminal on the battery is disconnected.
NEVER perform even routine
service (oil/filter changes, cleaning, etc.) unless all electrical components are shut down.
• NEVER allow water to accumulate around the base of the light tower. If water is present, DO NOT
service!
• NEVER service electrical components if clothing or skin is wet. If the unit is stored outside, check
the engine and generator for any moisture and dry the unit before use.
• NEVER wash the unit with a power washer or high pressure hose.
• Open main circuit breaker before disconnecting battery cables.
• Keep hands, feet, and loose clothing away from moving parts on generator and engine.
• Make sure slings, chains, hooks, ramps, jacks, and other types of lifting devices are attached
securely and have enough weight-bearing capacity to lift or hold the equipment safely. Always
remain aware of the position of other people around you when lifting the equipment.
SERVICE SAFETY