Engine Start Troubleshooting Tips
If the windrower will not start normally, refer to the following troubleshooting table:
IMPORTANT:
Do
NOT
tow machine to start engine. Damage to hydrostatic drives will result.
Table 4.2 Engine Start Troubleshooting
Problem
Solution
Controls not in NEUTRAL
• Move GSL to NEUTRAL
• Move steering wheel to locked position
• Disengage header clutch
Operator’s station not locked
• Adjust position of operator’s station
• Ensure lock is engaged
Neutral interlock misadjusted
• Contact MacDon Dealer
No fuel to engine
• Fill empty fuel tank
• Replace clogged
fi
lter
• Check for blocked or damaged fuel lines.
Old fuel in tank
• Drain tank
• Re
fi
ll with fresh fuel
Water, dirt, or air in fuel system
• Drain,
fl
ush,
fi
ll, and prime system
Improper type of fuel
• Use proper fuel for operating conditions
Crankcase oil too heavy
• Use recommended oil
Low battery output
• Test the battery
• Check battery electrolyte level
Poor battery connection
• Clean and tighten loose connections
Faulty starter
• Contact MacDon Dealer
Wiring shorted, circuit breaker open
• Check continuity of wiring and breaker (manually reset)
Faulty injectors
• Contact MacDon Dealer
Programming the Eco Engine Control (EEC)
Engine speed can be programmed to operate at reduced rpm to lower fuel and diesel exhaust
fl
uid (DEF)
consumption, and reduce in-cab noise levels. The set point for engine speed can be adjusted in increments of
100 rpm from 1800–2300 rpm in the Harvest Performance Tracker (HPT) QuickMenu. While the header is engaged,
the system can easily be activated and deactivated (depending on
fi
eld conditions) using the EEC button on the
console. When the engine is running at less than full speed, you will notice a small reduction in the maximum reel,
draper, and ground speeds.
214053
119
Revision A
Содержание M1240
