Drinking systems
floor watering system TwinClean Line
Copyright © 2018 Lubing System - All rights reserved
22
4.2.2 Cleaning of the dosers (if available)
A solution with EVC 12 is to recommended for cleaning (200 g per 10 litre 35°C warm water), that can be used
depending on the degree of pollution.
The prepared solution gets added for a few minutes just like the dosing medium via medicator. Let the cleaning
solution work over night. Afterwards it must be well flushed.
4.2.3 Cleaning of the water filter
A solulution with EVC 12 is recommended for cleaning (200 g per 10 litres 35°C warm water), that can be used
depending on the degree of pollution.
The filter cartridge gets accessible by turning off the filter cover. The cartridge has to be taken out and flushed.
The filter cartridge has to be dived from time to time. A contaminated filter cartridge causes a higher decrease of
pressure.
4.3 Vaccinating via drinking water
We recommend the following order for vaccination via drinking system:
– lock the water supply to the LUBING turkey drinker EasyLine
– let the drinking line drink up
– lift the drinking line
– start up the drinking system again with water and vaccines
– adjuct the hight of the drinking line
– after vaccination the drinking system has to be well flushed (see also “4.8 Flushing”).
4.4 Hutching in
In principle fresh and cool water should be offered to the animals. The water must be easily visibly offered and well
accessible for the animals.
Check the adjustment of the height. If necessary the drinking line has to be adjusted to the height of the animals.
An adjusting by setting of the litter in the initial phase can be necessary.
4.5 While rearing
The height adjustment has to be observed! A too low adjusted drinking line is easyer to pollute and drinking water
can be wasted.
4.6 While finishing
The height adjustement is ideal when the animals can stand upright and drink easily with a slight angled head.
4.7 Between the circles
At the end of each circle the LUBING drinking line has to be well cleaned and flushed.
4.8 Flushing
If an automatic flushing system is installed, the flushing procedure will be started at the controler LCW-8 or LCW-
max.
For manually flushing, the flushing valve at the pressure regulator must be opened so that the full volume of water
entering the drinking system. During flushing the Twinclean-Line principle both channels in the profile are flushed
at the same time.
Thus, the water flows through the two channels to the end. Also the small intake chamber and the pump in the
circulation unit will be flushed.
WARNING
The water needs a free out flow during flushing at the end of the drinking line!
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
lubingsystem.
com
