Instruction manual
10
Emergencies
Possible cause
Prevention/ Solution
Gas leaking from
cracked/cut/burned hose
Damaged hose
Turn off gas at LP tank, if hose is cut or
cracked, replace hose. See LP tank lead test
and connection regulator to the LP tank
Gas leaking from LP tank
Mechanical failure due to resting or
mishandling
Turn off LP tank valve. Return LP tank to gas
supplier
Gas leaking from LP tank valve .Failure of tank valve from mishandling or
mechanical failure
Turn off LP tank valve. Return LP tank to gas
supplier
Gas leaking between LP tank
and regulator connection
Improper installation, connection not tight,
failure of rubber seal
Turn off LP tank valve, remove regulator
from cylinder and visually inspect rubber
seal for damage, see LP tank test and
connection regulator to the LP tank
Fire coming through control
panel
Fire in burner tube section of burner due to
partial blockage
Turn off control knobs and LP tank valve.
After fire is out and grill is cold, remove
burner and inspect for spider nests or rust.
see natural hazard and cleaning the burner
assembly pages.
Troubleshooting: Problem
Possible cause
Prevention/ Solution
Grease fire or continuous
excessive flames above cooking
surface
Too much grease buildup in burner area
Turn off LP Tank. Leave lid open to allow
flames to die down. After cooling, clean food
particles and excess grease from inside firebox
area, grease cup/pan/tray, and other surfaces
Burner will not light using
ignitor
Gas issues
1.Trying to light wrong burner
2. Burner not engaged with control valve
3. Obstruction in burner
4.No gas flow
5.Vapor lock at coupling nut to LP tank
6. Coupling nut at LP tank valve not fully
connected.
1. See instructions on section Lighting
instructions
2. Make sure valve are positioned inside of
burner tubes.
3. Ensure burner tubes are not obstructed
with spider webs or other matted, see
cleaning section of use and care
4. Make sure LP tank is not empty.
5. Turn off knobs and disconnect coupling nut
from LP tank. Reconnect and retry.
6. Turn the coupling nut approximately one-
half to three-quarters