Section 7: Lubrication and Fluids
4400EX Heavy Duty Off Road Utility Vehicle 720-051M
7/14/08
32
Table of Contents
Engine Oil and Filter Change
Refer to Figures 7-1, 7-2, 7-3, 7-4 & 7-5
Drain used engine oil while the engine and oil are still
warm. The oil will drain more freely and carry away more
impurities. Change oil as follows:
1.
Prepare vehicle for maintenance as outlined in steps
1-6 on page 22.
2.
Clean the area around the oil filter to keep dirt and
debris out of the engine.
3.
Place a suitable container below the engine to catch
used oil as it drains. Remove filler cap. Turn oil drain
valve 1/4 turn counterclockwise and pull out to drain
oil.
4.
Remove oil filter located on left side of engine with a
filter wrench. Let remaining oil drain out.
5.
Push oil drain valve in and turn clockwise until hand
tight. Replace oil drain cap.
6.
Clean oil filter base where the oil filter seats against it.
7.
Place a new replacement filter in a shallow pan with
the open end up. Pour new engine oil in through the
threaded center hole until oil reaches the bottom of
the threads. Allow one or two minutes for the oil to be
absorbed by the filter material.
8.
Coat new filter O-ring with clean engine oil and install
filter to engine filter base.
9.
Hand tighten oil filter until O-ring seats. Finish
tightening by turning in the filter an additional 2/3 to 1
turn.
10. Dispose of used motor oil and filter in a manner that is
compatible with the environment. Do not throw used
oil in the trash, pour it on the ground, or down a drain.
11. Fill engine with recommended oil and quantity. Do not
overfill. See "Engine Oil Type and Capacity" and
"Engine Oil Level Check" on page 31.
12. Replace filler cap, start engine and check engine and
oil filter for leaks. Correct any leaks before placing
engine into service.
13. Stop engine and check oil level. Add additional oil if
not to the full mark “F” on the dipstick.
6mo/100hrs
figure 7-3
Figure 7-4
Oil Filter O-Ring
Figure 7-5
Oil Drain Cap
Oil Drain Valve
21363
Oil Filter
Base
Oil Filter
21371
21134