Kubota D662-E, Руководство оператора

Страница: 23 / 38

13 PERIODIC SERVICE
EN
GLISH
B
Cleaning the fuel filter pot
Every 100 hours of operation, clean the fuel filter in a
clean place to prevent dust intrusion.
1. Close the fuel filter lever.
2. Remove the top cap, and rinse the inside with diesel
fuel.
3. Take out the element, and rinse it with diesel fuel.
4. After cleaning, reinstall the fuel filter, keeping out of
dust and dirt.
5. Air-bleed the injection pump.
A Entrance of dust and dirt can cause a malfunction of
the fuel injection pump and the injection nozzle. Wash
the fuel filter cup periodically.
ENGINE OIL
To avoid personal injury:
A
Be sure to stop the engine before
checking and changing the engine
oil and the oil filter cartridge.
A
Do not touch muffler or exhaust
pipes while they are hot; Severe
burns could result. Always stop the
engine and allow it to cool before
conducting inspections,
maintenance, or for a cleaning
procedure.
A Contact with engine oil can damage
your skin. Put on gloves when using
engine oil. If you come in contact
with engine oil, wash it off
immediately.
A Be sure to inspect the engine, locating it on a
horizontal place. If placed on gradients accurately, oil
quantity may not be measured.
A
Be sure to keep the oil level between upper and lower
limits of the oil gauge. Too much oil may cause a drop
in output or excessive blow-by gas. On the closed
breather type engine in which mist is sucked through
port, too much oil may cause oil hammer. While too
little oil, may seize the engine's rotating and sliding
parts. (The closed breather is an option.)
B
Checking level and adding engine oil
1. Check the engine oil level before starting or more than
5 minutes after stopping the engine.
2. Remove the oil level gauge, wipe it clean and reinstall
it.
3. Take the oil level gauge out again, and check the oil
level.
(1) Fuel filter lever
(2) Fuel filter pot (A) "OFF"
(B) "ON"
(1) O ring
(2) Filter element
(3) Spring
(4) Filter bowl
(5) Screw ring
(1) Oil filler plug
(2) Oil level gauge [Lower end of oil level gauge]
(A):Engine oil level within this
range is proper.
E.book 13 ページ ２０１１年５月３１日 火曜日 午後３時４５分