Keating Of Chicago Instant Recovery PRE-2000 Series, Руководство пользователя

Страница: 10 / 31

|
keatingofchicago.com
8
Figure 6 - Drain and Drain Valve
2. Turn off the fryer and open the door.
3. For front drain fryers, put approved container
under drain valve. For fryers with a central fi lter,
slide fi lter drawer in completely.
4. • Front Drain:
Slowly turn handle forward to avoid splashing.
The drain will be completely open after 1/4
turn.
• Rear Drain:
Slowly pull drain valve operating handle straight
out (unhook from metal latch fi rst).
5. After fryer drains, close the drain valve.
6. Filtering may be done at this step - refer to fi lter
manual.
Figure 7 -
Nutroilator Filter and Fryer
UNDER NO CIRCUMSTANCES SHOULD YOU PERMIT
HOT OIL TO COME IN CONTACT WITH WATER OR
ICE. ALL DRAINING SHOULD BE DONE UNDER THE
SUPERVISION OF PROPERLY TRAINED PERSONNEL.
A DRAIN PIPE AND COVERED CONTAINER SUITABLE
FOR USE WITH HOT OIL SHOULD BE USED
WHENEVER A FRYER IS DRAINED. ALWAYS DRAIN
OIL INTO A COVERED RECEPTACLE.
CLEANING AND BOIL-OUT
When cleaning and boiling out your fryer use Keating
Sea Powder and Keating Klenzer to keep your fryer
in top condition. Keating Sea Powder dissolves any
grease build up - even carbonized grease in fryer
vessels - one of the leading causes of premature
oil breakdown. Once your fryer vessel is clean, use
Keating Klenzer, the fi nest dry stainless steel polish
available, to restore your Keating Instant Recovery®
Gas Fryer’s exterior to its original luster.
Disconnect electric power source before cleaning.
To avoid damaging the fryer, do not power wash, spray
or hose it down while cleaning it.
1. Put on safety attire. See Draining.
2. Turn the fryer off.
3. Drain oil from fryer. Filtering may be done at this
step.
4. Remove oil container to a secure area to prevent
accidental spillage.
5. Fill fryer vessel to “Fill Level” line with water.
UNDER NO CIRCUMSTANCES SHOULD THE FRYER
BE LEFT UNATTENDED DURING BOIL-OUT. TRAINED
PERSONNEL MUST BE PRESENT DURING THE
PROCEDURE TO PREVENT BOIL OVER OR TO TURN
OFF THE POWER IF WATER DROPS BELOW HEAT
TRANSFER TUBES.
6. Set thermostat and turn fryer on to bring water to
a gentle boil.
7. Once boil has been reached, turn fryer off.
Figure 8
Keating Klenzer
and Sea Powder
Front Drain
RETURN VALVE
HANDLE
DRAIN VALVE
HANDLE
Rear Drain