KAYO MOTOR T2, Руководство по обслуживанию

Страница: 60 / 61

ZHEJIANG KAYO MOTOR CO., LTD.
www.kayomoto.us - 59 -
Float chamber fuel level is too low
Adjust float chamber fuel level to specified
height
Idle speed is
too high
The throttle spring of carburetor has too little
tension
Replace spring
Too much idle clearance Replace carburetor
unstable idle
ignition timing is wrong Adjust ignition time as specified
Mixture too thick or too thin Adjust the carburetor
spark plug clearance is too small Adjust clearance to specified value
3
．
The engine is unstable
Fault clues fault cause elimination methods
Fuel line Fuel line is at semi-blocked state Dredge fuel line
Electric device
Leakage of high voltage wire or ignition coil replace
Broken or leakage of capacitor replace
Too much carbon deposit between spark plug
electrodes
Eliminate carbon deposit
4
．
engine overheat
Fault clues fault cause elimination methods
Overload or long
time running at
high speed
To operate in low gear or on bad roads for long periods
of time
Improve operation or stop
temporarily
Work under full throttle for long hours Adjust the throttle properly
clutch slipping adjust
Muffler clogged clean carbon deposits

fuel
system problem
fuel mix ratio is wrong adjust the carburetor
Gas mixture too thick or too thin Adjust the carburetor
5
．
engine stopped
Fault clues fault cause elimination methods
fuel system problem
Fuel is used up refuel
Fuel is not
available
Fuel line is blocked Clean the fuel line
Carburetor is blocked Clean the carburetor
Electric device Cut off
Check electrical wiring from spark
plug to magneto in sequence
engine is locked or Serious cylinder block, piston block Repair or replace