15
FNS-0006-060-EN November 2017 Rev F
9.
Scrub
components.
Use a brush, towel, or sponge.
DO NOT
use abrasive pads such as Scotch Brite®,
steel wool, etc. Thoroughly rinse with clean water, then thoroughly rinse with
sanitizer solution. Follow the manufacturer's mixing directions and safety
precautions. As an alternate cleaning method, all juicing components can be put in
a dishwasher. If this method is used, components should be washed in CorKlean
at least once a week.
DO NOT
soak aluminum cups longer than 30 min. Then,
rinse and sanitize.
10.
For
best
results,
soak
strainer tube
in
CorKlean
overnight.
After soaking overnight, rinse the strainer tube thoroughly before using. Check that
all strainer tube holes are clean. Clean strainer tube with a hard spray from a hose
while moving orifice tube back and forth in strainer tube.
Rinse
thoroughly
with
sanitizer
solution. Allow
to
air
dry.
11.
If possible, hose down juicing area and cover.
If location prohibits using a hose to clean juicing area and cover, ensure waste
container is in place. Wash down the exposed juicing area and cover with a
sponge or spray applicator using the recommended cleaning solution. Cover may
be rinsed in place. Allow to stand for two minutes before rinsing thoroughly with
water.
12.
Re-assemble juicing components.
Start by re-assembling strainer tube into juice manifold, and tightening. Insert
orifice tube into bottom of strainer tube. Mount juice manifold assembly onto
locating pins with orifice tube notch engaging lower drive. Remove red protective
cap from cutter. Install lower cup and be sure spring snaps into pin grooves.
Install
upper cup
by
slipping
pin
into
stem
hole,
and
turning
until
alignment
pin
engages
cup.
Be
sure
spring
engages.
13
.
CorKlean solution can also be used to remove smudges and finger marks from
aluminum exterior of Citrus Juicer. This should be done periodically to maintain the
exterior appearance of the machine.
14.
Remove wax build-up as needed. (1 tablespoon of ammonia in 32 oz. spray bottle)
Cups, feed chute, and other parts may acquire a build-up of wax overtime.
a. Soak cups for five minutes in an ammonia cleaning solution. Rinse thoroughly
with sanitizer solution.
b. Wipe feed chute and other parts with a cloth soaked in ammonia cleaning
solution. Rinse thoroughly with sanitizer solution.
15.
Remove orange discoloration as needed.
Equipment may exhibit some build-up or orange coloration over time. Wipe with a
cloth soaked in CorKlean solution. Rinse thoroughly with sanitizer solution.
Содержание Fresh'n Squeeze Citrus Juicer
