Indeeco 110-Z3, Руководство по эксплуатации

Страница: 6 / 32

INPUT CONTROL SIGNAL:
Connect the control signal to the blue terminal block labeled "4-20mA INPUT" observing proper polarity (positive
to "+" and negative to "-").
Terminal torque is 5 In-Lbs for mA input block.
THERMOSTAT for FAN FAILURE:
On all INDEECO SCR Controls 150 Amps and above, fans are used to cool the SCR heat sinks. INDEECO mounts
a Snap-disc thermostat to the heat sink. If the fan fails, air is blocked or a safe ambient temperature is exceeded, the
thermostat will activate. This thermostat can be used to break I/O relay logic, trigger alarms or shut down a power
contactor. See wiring diagram for thermostat wiring page 16.
OPTIONS
"
R " RELAY OPTION: For 10-32 VDC or 120VAC Signal Input to turn 110-Z3 into On/Off controller,
use "R" relay option. Call out as " -R32 " or " -R120 "
For manual control use INDEECO model
MAP . Isolated Potentiometer 4-20mA signal card.
For LINEAR 0-5 or 0-10 VDC Analog Signal use MAI milliamp interface card.
MAI-05V takes a 0-5VDC signal input and outputs 4-20mA.
MAI-10V takes a 0-10VDC signal input and outputs 4-20mA.
For third Leg Fusing add
"-3RD " to part number. All fuses come mounted to chassis w/lugs. Higher amp
fuse (over 100A) come with block & lugs.
WARRANTY
All INDEECO 110-Z3 SCRs carry a full five year , warranty from date of purchase, parts and labor
warranty against component failure and defects in workmanship. In the event your controller fails to
perform properly,
contact INDEECO to obtain a return authorization number . Controllers sent to
INDEECO for warranty service that have no apparent defect will be treated as a standard repair and a
$50.00 charge will be applied. INDEECO will repair or replace any unit that failed due to defective parts
or assembly. This warranty DOES NOT cover damage due to shipping, abuse, misapplication or
operation beyond specified rating. Furthermore, fuses and improperly fused SCR's are NOT COVERED
by this warranty. INDEECO is not responsible for any subsequent or other damage experienced in use of
this device.
Page 6