IMCO Xtreme Advantage scX4, Руководство по обслуживанию

Страница: 2 / 20

Recommended oil: Torco RTF GL-6 (Torco Part #A220015CE (unit) Part # S220015C (case) IMCO Part #
09-2600 (unit) Part # 09-2605 (5 Gal.) Part # 09-2610 (case) (100% Synthetic Raceing Transmission
Fluid) Replaces SAE 75W90.
To drain oil: remove drain screws from bearing carrier (right below the prop shaft) and on port side of
upper.
To replace oil: pump oil in from lower drain screw until it comes out of upper drain screw hole. Replace
drain screws and add oil to drive oil reservoir.
When changing oil, run the used oil through a strainer to check for metal particles, if ther are metal
particles in the oil it is time for inspection of the gears and bearings. If oil appears milky or off colored
check for leaks.
SCX, SCX4 capacity: 5 qts + reservoir - SCX Upper with SC Lower 4 1/2 qts + reservoir.
19. Drive must be turning before shifting.
20. Do not run engine when drive is trimmed extremely high, or in trailer tow mode.
21. Do not use solvents or chemical cleaners to clean painted surfaces on the drive.
22. When installing or changing propeller use extreme caution, propeller blades can
be very sharp.
23. SCX upper vertical shaft is 17 tooth spline, SC, Merc lowers are 15 tooth spline. A 17-15 tooth
coupler is available 01-2150 (cannot be used with a spacer).
24. Use extreme caution if modifying lower, case can be weakened or handling can
be adversely affected.
25. Break in: Do not use full throttle until drive is fully warmed up, do not hold drive at wide open throttle
for more than 2 minutes for the first 3 hours of use.
26. Inspect anode (located on front of cavitation plate) for corrosion or debris; if necessary clean or
replace.
27. Do not shift drive while running on hose with
propeller installed.
28. Rotation: shift linkage pushed in - right hand rotation, shift
linkage pulled out - left hand rotation.
29. Serial # location: Port side below SCX, SCX4 sticker
3/10/14
SCX Upper & SCX Lower
New Break in
20 hours
After Break In
80 hours
SCX4 Upper & SCX4 Lower
New Break in
20 hours
New Break in
20 hours
SCX Upper & SC Lower
After Break In
80 hours
Check Drain Plug Magnet
Every 20 Hours
Warning!
Warning!
Caution!
Warning!
Caution!
Caution!