24
31282 Rev Q
09/04
CALIBER B-VENT INSTALLATION INSTRUCTIONS
4. Clean the Glass
See Figure 33. Never operate this appliance without the glass properly secured in place or if the glass is broken.
In the event of glass breakage, carefully remove the glass frame. This will allow the removal of all glass fragments
and sheet metal edge protection strips. Vacuum all remaining glass pieces with a shop vac.
DO NOT VACUUM IF
PIECES ARE HOT!
Replace glass with only a Hearth & Home Technologies glass panel assembly ordered direct or
through your local distributor. Never use substitute material. Only fully tempered soda lime safety glass or ceramic
glass may be used on this appliance.
Figure 33 - Glass Cleaning
Safety Note:
Handle glass with care
to avoid striking,
scratching or slamming
shut.
NEVER
clean
glass when it is hot.
Keep children and pets
a safe distance away.
5. Log Removal/Replacement
If removal of the logs becomes necessary, remove
the two screws, one at each end of the grate. Grasp
the grate as shown. Grasp the grate and pull the logs
up and off the burner. See Figure 34.
To replace the logs, grasp the grate as shown. Lower
the log set onto the burner pan, making sure the tabs
on the front of the grate line up with the holes provided.
Attach the two screws at each end of the grate.
Figure 34 - Log Removal
Pull out to
remove the
upper grill
and expose
the two/
three Quick
Access
Latches.
Open control
access panel to
expose two/
three Quick
Access
Latches.
Rotate Bottom of
screen away from
the appliance and
lower out of the top
retainers. Set screen
aside.
Pull and release the
four/six Quick
Access Latches.
Pull top of glass
away from
appliance.
Set glass on
nonabrasive
surface. Clean using
a nonabrasive, mild
cleaning solution
(i.e. Brasso).
To replace, place the
glass on the bottom
retainers. Glass
must be firmly
seated into the
bottom glass
retainers.
Reattach the
four Quick
Access
Latches.
Place the screen into the top
screen retainers, lift and rotate
towards the appliance. Place
on the bottom retainers.
Close the control
access panel.
Replace the
upper grille.
1
2
3
4
5
6
7
8
9
10
11
f i r e - p a r t s . c o m
