Emergency stop
-Verify that the lift unit does not operate when emergency stop is pressed in.
Electric emergency lowering
-Verify the function of emergency lowering. Use a narrow object such as a pen.
Charging
-Verify that charging is operating. Yellow lamp on the controllbox should light up when charging.
Product label
- Check the serial number so that the label is there and readable. Note the serial number on the protocol.
Test loading
Test loading of MiniLift200 is done with 150 kg weight, which corresponds to a user weight of 200 kg.
Test loading with loose weights
NOTE! Both hooks must bear the weight. When one weight is used, the weight
must be distributed over both hooks. Ensure that the weight pack is well clear of the actuator.
Weights must be attached to the hooks as shown in picture.
Remove the lower-leg support and footrest before test loading; this allows
more space for the weight that is to be lifted.
NOTE! Replace the lower-leg support and footrest after test loading.
Move the lift arm to the outermost position and apply 150 kg.
- Run the actuator 160 mm up/down as shown in picture. The lift arm is loaded
with 150 kg and placed in the outermost position.
Listen for unusual sounds during raising/lowering.
Connector hooks
- Lift 150 kg clear of the floor and wait for 20 sec.
NOTE! Load the hooks according to picture.
The base is loaded with 200 kg.
- Place 200 kg on the footrest, within the frame for foot placement. Run the base-width adjustment in/out and listen for
unusual sounds.
Mechanical emergency lowering
-Verify the function of emergency lowering. With the lift loaded, round plastic knob on the actuator clockwise.
Documentation
- Check that the manual is available and up-to-date.
Accessories
-Check the accessories to the lift unit.
To reset the service counters press both lift buttons on the hand control at the same time for 5 seconds.
An audio signal will indicate that the timer has been reset.
17
System
RoMedic
TM
Содержание SystemRoMedic MiniLift200
Страница 5: ...Exploded view and components 5 SystemRoMedic TM...
Страница 15: ...Description for periodic inspection 15 SystemRoMedic TM A A G E L J M I K F B A H...
Страница 22: ...22 SystemRoMedic TM...
Страница 23: ...23 SystemRoMedic TM...