6 OM-NEB/1
Boiler overfills with
water.
User
a. Is the boiler level? Check levelness of unit
with a spirit level.
b. Is the water pressure too high? (Greater
than 60 PSI?)
Authorized
Service Rep
Only
c. Is the Water Level Control Board defective?
Check for loose electrical connections on
“hi” water fill solenoid. (X)
d. Is the water fill solenoid valve defective? (X)
Check for debris on valve seat.
e. Is the “hi” water probe sensing level? Clean
water level probe and probe well (located in
boiler). (X)
Boiler under fills
with water.
User
a. Is the boiler level? Check levelness of unit
with a spirit level.
Water enters boiler
slowly.
User
a. Is strainer screen (if used) clogged?
b. Is the water pressure too low? (Less than
30 PSI)?
c. Is the water supply line too small?
Authorized
Service Rep
Only
d. Is the water fill solenoid defective? (X)
RESET light does
not come on.
Authorized
Service Rep
Only
a. Is the Is the Water Level Control Board
defective? Check for loose electrical
connections on “mid” water fill solenoid. (X)
b. Is the “mid” water probe sensing level?
Clean water level probe and probe well
(located in boiler). (X)
c. Is the indicator light defective? (X)
Heater(s) will not
come on.
Authorized
Service Rep
Only
a. Are contactors defective? (X)
b. Is the heater burned out? Check voltage
and amperage on each line at each heater.
(X)
c. Is the contactor control relay defective?
Note: Relay controls all contactor coils. (X)
Boiler does not
build pressure with
heaters on.
User
a. Is the steam power take-off valve open or
leaking?
b. Is the pressure gauge defective?
Authorized
Service Rep
Only
c. Is the air vent leaking steam? (X)
d. Is the solenoid or manual drain valve open
or leaking? NOTE: Excessive make-up
water added to the boiler reduces steam
production. (X)
Heater(s) does (do)
not shut off after
reaching operating
pressure.
Authorized
Service Rep
Only
a. Is the pressure gauge defective? (X)
b. Is the operating pressure switch defective?
No adjustment is allowed. Replace the
switch if defective. (X)
c. Are the contactors defective? (X)
d. Is the contactor control relay defective? (X)
Boiler builds
pressure but
shuts down. RESET
light comes on.
User
a. Is the water level below the “mid” water
level probe? Verify that the water supply is
sufficient to maintain the water level at or
above the “mid” water level probe.
Authorized
Service Rep
Only
b. Is the operating pressure switch defective?
No adjustment is allowed. Replace the
switch if defective. NOTE: If the high-limit
pressure switch has shut down the unit, it
should not be restarted until the problem
which caused the shut-down has been
corrected. (X)
c. Is the “mid” water level probe unable to
detect water? Clean the water level probe
and probe well (located in the boiler). (X)
Safety relief valve
opens.
Authorized
Service Rep
Only
a. Are the operating pressure switch and/or
high-limit pressure switch defective? No
adjustment is allowed. Replace defective
switches. (X)
b. Is the safety relief valve defective? Replace
with ASME approved 15 PSI valve with “HV”
marking. (X)
Boiler blows down
immediately when
turned off.
Authorized
Service Rep
Only
a. Is the thermostatic switch defective? Check
for loose electrical connections on switch.
(X)
Boiler does not
drain.
User
a. Is the thermostatic switch defective?
b. Is the solenoid drain valve defective?
c. Are the solenoid drain valve or hoses
blocked?
WARRANTY
Congratulations on the purchase of your new Unified Brands equipment. We hope you
enjoy many years of reliable service in connection with the same. Please review all of
the important safety and operational information contained in the Operator’s Manual
for this equipment before it is placed in service. If you have any questions related to
equipment set up, operations, or service, please call 888-994-7636.
In addition, please review the sales terms and conditions set forth below.
*****IMPORTANT NOTICE*****
WARRANTIES, LIMITATIONS ON WARRANTIES, AND LIMITATION OF REMEDIES
The following Warranties, Limitation on Warranties, and Limitation of Remedies are
included in the terms of sale for this product. Please read this entire warranty and all
warranty modifications, disclaimers, and limitations of remedies set forth herein before
accepting or using this equipment or product. Customer acknowledges and accepts
the provisions of this notice by Customer’s acceptance and use of the product. If these
provisions are not acceptable and agreed to by Customer, then please return this
product in its unused condition to Unified Brands or a Unified Brands authorized dealer.
UNIFIED BRANDS warrants this product against defects in material and workmanship
under normal use and services for which this product was designed. This warranty
runs only to the original end user and is in lieu of any other liability for defects.
THE WARRANTIES EXPRESSED IN THESE TERMS AND CONDITIONS ARE IN PLACE
OF ANY AND ALL OTHER EXPRESS WARRANTIES (UNLESS SEPARATELY STATED IN
PRINTED MATERIAL PREPARED BY US DESCRIBING OUR EQUIPMENT) AND EXCLUDE
ALL IMPLIED WARRANTIES, INCLUDING, BUT NOT LIMITED TO, ANY WARRANTY OF
MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR PURPOSE; NOR ARE THERE
ANY OTHER WARRANTIES, EXPRESS OR IMPLIED, BY OPERATION OF LAW OR
OTHERWISE. In no event shall UNIFIED BRANDS be liable for damages or delay or
for any consequential, special or contingent damages arising out of any breach of
our warranty, whether or not we have knowledge of specific needs or our employees
or agents have given any specific assurances. Anyone claiming that there has been
a breach of warranty by UNIFIED BRANDS must give us written notice within THIRTY
(30) days after discovery of the relevant defect or the right to assert such claim will
have been waived conclusively and provided further that any such claim must also be
asserted within the general warranty period for such equipment and/or parts.
UNIFIED BRANDS will not be liable for any expense incurred without our prior written
authorization for alterations made outside of our factory or for repairs which are
not performed by UNIFIED BRANDS authorized service departments using UNIFIED
BRANDS factory parts. Nor shall we be responsible for the performance of equipment
as to which any repairs, revisions or alterations have been made by others.
THE EXCLUSIVE REMEDY OF THE USER OR BUYER AND THE EXCLUSIVE LIABILITY OF
UNIFIED BRANDS OR ANY SELLER OF UNIFIED BRANDS PRODUCTS, FOR ANY AND ALL
CLAIMS, LOSSES, INJURIES, OR DAMAGES (INCLUDING CLAIMS BASED ON BREACH
OF WARRANTY, CONTRACT, NEGLIGENCE, TORT, STRICT LIABILITY, OR OTHERWISE)
RESULTING FROM OR ARISING OUT OF THE USE OF HANDLING OF THIS PRODUCT,
SHALL BE THE RETURN OF THE PURCHASE PRICE OR AN AMOUNT NOT TO EXCEED
THE ORIGINAL PURCHASE PRICE OF THE PRODUCT OR, AT THE ELECTION OF UNIFIED
BRANDS OR THE SELLER, THE REPLACEMENT OF THE PRODUCT.
https://unifiedbrands.net/
Groen-Warranty-Information
