16
MAINTENANCE AND CLEANING
You may solve the problems you may encounter with your product by checking the
following points before calling the technical service.
CHECK POINTS
In case you experience a problem about the oven, fi rst check the table below and try
out the suggestions.
MAINTENANCE AND CLEANING
CATALYTIC PANEL *
It is located behind the wire racks of the oven, at the right and left walls of oven cavity.
Catalytic panel removes off ensive odour and provides using your appliance at its best
performance. Over time, oil and food odours permeate into enamelled oven walls and
heating elements. Catalytic panel absorbs any food and oil odours, and burns them
during cooking to clean your oven.
DETACHING CATALYTIC PANEL
To remove catalytic panel; fi rst remove the wire racks. Once wire racks are removed,
catalytic panel will be free. It is advised to replace the catalytic panel once every 2-3
years.
RACK POSITIONS
In order to remove the catalytic walls; the guides must be pulled out. As soon as the
guides are pulled out, the catalytic walls will be released automatically. The catalytic
walls must be changed after 2-3 years.
INSTALLING AND REMOVING WIRE RACKS
To remove wire racks, press the clips
shown with arrows in the fi gure, fi rst
remove the lower, and than the upper
side from installation location.
To install wire racks; reverse the
procedure for removing wire rack.
REPLACING OVEN LAMP
WARNING: To avoid electric shock, ensure that the appliance circuit is
open before changing the lamp. (having circuit open means power is off )
First disconnect the power of appliance and ensure that appliance is cold.
Remove the glass protection by turning as indicated in the fi gure on the left side. If you
have diffi
culty in turning, then using plastic gloves will help you in turning.
Then remove the lamp by turning, install the new lamp with same specifi cations.
Reinstall glass protection, plug the power cable of appliance into electrical socket and
complete replacement. Now you can use your oven.
TROUBLESHOOTING
Figure 25
220-240 V, AC-
15-25 W
220-240 V, AC
15 W
Figure 26
Type G9 Lamp
Type E14 Lamp
Rack 4
Rack 3
Rack 2
Rack 1
Problem
Possible Cause
What to Do
Oven does not
operate.
Power supply not
available.
Check for power supply.
Gas supply not available.
Check if main gas valve is open.
Check if gas pipe is bent or
kinked.
Make sure gas hose is
connected to the oven.
Check if suitable gas valve is
being used.
Oven stops during
cooking.
Plug comes out from the
wall socket.
Re-install the plug into wall
socket.
Turns off during
cooking.
Too long continuous
operation.
Let the oven cool down after
long cooking cycles.
More than one plugs in a
wall socket.
Use only one plug for each wall
socket.
Oven door is not
opening properly.
Food residues jammed
between the door and
internal cavity.
Clean the oven well and try to
re-open the door.
Electric shock when
touching the oven.
No proper grounding.
Make sure power supply is
grounded properly.
Ungrounded wall socket
is used.
Water dripping.
Water or steam may
generate under certain
conditions depending
on the food being
cooked. This is not a fault
of the appliance.
Let the oven cool down and
than wipe dry with a dishcloth.
Steam coming out
from a crack on
oven door.
Water remaining
inside the oven.
Oven does not heat.
Oven door is open.
Close the door and restart.
Oven controls not
correctly adjusted.
Read the section regarding
operation of the oven and
reset the oven.
Fuse tripped or circuit
breaker turned off .
Replace the fuse or reset
the circuit breaker. If this is
repeating frequently, call an
electrician.
Smoke coming out
during operation.
When operating the
oven for the fi rst time
Smoke comes out from the
heaters. This is not a fault. After
2-3 cycles, there will be no
more smoke.
Food on heater.
Let the oven to cool down and
clean food residues from the
ground of the oven and surface
of upper heater.
When operating
the oven burnt
or plastic odour
coming out.
Plastic or other not heat
resistant accessories are
being used inside the
oven.
At high temperatures, use
suitable glassware accessories.
Oven does not cook
well.
Oven door is opened
frequently during
cooking.
Do not open oven door
frequently, if the food you
are cooking does not require
turning. If you open the
door frequently internal
temperature drops and
therefore cooking result will be
infl uenced.
Internal light is dim
or does not operate.
Foreign object covering
the lamp during cooking.
Clean internal surface of the
oven and check again.
Lamp might be failed.
Replace with a lamp with same
specifi cations.
