2
Table of Contents
Table of Contents .......................................................... 2
Performance .................................................................. 2
Safety Information ......................................................... 2
Warranty ......................................................................... 3
Pre-Installation .............................................................. 4
Installation ..................................................................... 6
Operation ....................................................................... 6
Airlock ............................................................................ 7
Care and Cleaning ........................................................ 7
Troubleshooting ............................................................ 9
SKU
HP
GPH of Water @ Total Feet Of Lift
Max. Lift
0 ft.
5 ft.
10 ft.
15 ft.
20 ft.
1001627571
1/8
1800
1560
1320
960
240
21 ft.
Safety Information
DANGER
:
Do not pump flammable or explosive liquids such as
oil, gasoline, kerosene, ethanol, etc. Do not use in the presence
of flammable or explosive vapors. Using this pump with or near
flammable liquids can cause an explosion or fire, resulting in
property damage, serious personal injury, and/or death.
WARNING
:
Wear safety goggles at all times when working
with pumps.
WARNING
:
This unit is designed only for use on 115 volts
(single phase), 60 Hz, and is equipped with an approved
3-conductor cord and 3-prong grounded plug. Do not remove
the ground pin under any circumstances. The 3-prong plug must
be directly inserted into a properly installed and grounded
3-prong, grounding-type receptacle. Do not use this pump with
a 2-prong wall outlet. Replace the 2-prong outlet with a properly
grounded 3-prong receptacle installed in accordance with the
National Electrical Code and local codes and ordinances. All
wiring should be performed by a qualified electrician.
DANGER
:
ALWAYS disconnect the power to the pump before
servicing.
DANGER
:
Do not touch the motor housing during operation.
The motor is designed to operate at high temperatures. Do not
disassemble the motor housing.
WARNING
:
Protect the electrical cord from sharp objects, hot
surfaces, oil, and chemicals. Avoid kinking the cord. Do not use
damaged or worn cords.
DANGER
:
Do not handle the pump or pump motor with wet
hands or when standing on a wet or damp surface, or in water
before disconnect the power.
WARNING
:
Failure to comply with the instruction and
designed operation of this unit may void the warranty.
ATTEMPTING TO USE ADAMAGED PUMP can result in property
damage, serious personal injury, and/or death.
WARNING
:
Release all pressure and drain all water from the
system before servicing any component.
WARNING
:
Secure the discharge line before starting the
pump. An unsecured discharge line will whip, possibly causing
personal injury, and/or property damage.
WARNING
:
Ensure that the electrical circuit to the pump is
protected by a 10 Amp fuse or circuit breaker.
WARNING
:
Extension cords may not deliver sufficient voltage
to the pump motor. Extension cords present a life threatening
safety hazard if the insulation becomes damaged or the
connection ends fall into water. The use of an extension cord to
power this pump is not permitted.
.
CAUTION
:
Do not lift the pump by the power cord.
Performance
