Eagle EG6088K, Руководство по эксплуатации, Страница: 17 / 24

- 14
7.7 Running-in of New Vehicle:
In order to guarantee the performance of the vehicle and enhance its reliability and working lift, all parts in
motor should experience a certain period of running-in before the motor works with its maximum capacity, thus,
each new vehicle is required to give one month of running-in time, detail procedure as per the following:
①
C
heck the levels of oil, water and liquids carefully before running-in and fill them as requested if insufficient.
The tire should meet 145R12 with the air pressure of 3.5kgf/cm
2
.
②
During running-in time, the speed should be limited as follows:
Current Shift
Model
1 2 3 4
EG6088 100A 50A 50A 55A
EG6118KA, EG6118KB 110A 55A 50A 65A
EG6158K 110A 60A 55A 70A
③
If possible, try your best to avoid driving on poor conditions roads.
④
Check and tighten regularly the fixing parts of each connecting points.
Notes:
1) To avoid any damage on the brake shoe, handbrake should be released to its bottom before staring the
vehicle.
2) The lubricant for rear power assembly must be applied and changed as per user
’
s manual.
3) The brake system must be adjusted once every 3 months.
4) The electricity system must be checked once every 3 months (especially main circuit) for its fastening parts
and wiring connections. Meanwhile the contactor should be checked, any defective parts should be
replaced immediately. Its dust should be cleaned by low pressure air.
5) The electric contactors easily become hot if their mutual contact is not in good condition, so special
attention should be paid regularly to the electric contactors.
6) When changing the fuse, make sure that the new fuse is right in rated current.
7) For the sake of safety, disconnect the positive pole from the battery when maintenance is done.
8) Never step the accelerator hard and frequently, which may shorten the life of the controller.
9) It is prohibited to fill any other liquids (such as battery addictives, mineral water and tap water) into the
battery, ONLY the distilled water is allowed to fill in the battery.
10) Do not drive at high speed when going downhill; slow down the vehicle when turning; and remind the
passengers to hold on when turning and going downhill.
11) Children are not allowed to play in the vehicle; Children should be seated between adults and vehicleed by
adults when the vehicle is running.
12) Periodic Maintenance Charts
Regular maintenance is required for the best performance and safe operation of the vehicle.