dentronix DDUS60, Руководство пользователя

Страница: 5 / 9

Owners Guide 5
Basket Section Inserts. Place instruments across ridges in bottom
of basket. Place basket in tank and clean for desired time.
D. DDUS60I – Basket Section Inserts
Place the “H” shaped Section Supports into the holes of the
raised ridge on the bottom of the basket. The tapered end
should be pointing up. Insert the flat Basket Section inserts into
the slots of the “H” shaped supports. For optimum stability, place
the supports at equal distance from the basket walls.
E. DDUS60C – Beaker Positioning Cover
Place the Beaker Positioning Cover on bezel. Place rubber ring
around the beaker so that at least 1/3 of the beaker is suspended
in the main bath. Clean for desired time. To reduce aerosols, place
white plastic beaker cover over the beaker during operation.
F. DDUS60S –
Hu-Friedy IMS
(1)
/ Thompson
(2)
Instrument Cassette Racks
This rack will hold three (3) large or six (6) small cassettes. Up
to three (3) large cassettes may be placed horizontally in each
of the three tiers of the rack. Up to six (6) small cassettes can be
placed either horizontally or vertically in the rack. Place filled
rack in tank containing Dentronix solution. Once cassette
contents or instruments are cleaned, remove rack from tank and
tilt back over tank to drain (rack has stops on the back to prevent
the cassettes from sliding out
(Fig. 7) . Rinse rack and cassettes
on all sides thoroughly under running tap water. Place rack on
draining tabs of unit bezel to dry. (See Instrument Draining
section (III-D) for more details.)
(1) a registered trademark of Hu-Friedy Inc.
(2) a registered trademark of Thompson Inc.
VI. Environmental Conditions
• Intended for indoor use.
• Maximum altitude 2000m.
• Temperature range 5°C to 40°C.
• Maximum relative humidity 80% for temperatures up to 31°C,
decreasing linearly to 50% relative humidity at 40°C.
• Mains supply voltage fluctuations not to exceed 10% of the
nominal voltage.
• Transient over voltages category II.
• Pollution degree 2.
• Class I equipment.
VII. Warnings
• Do not operate the unit without sufficient solution in the tank.
• Do not use water alone as the carrier bath. Water is not a
satisfactory coupling agent unless a wetting agent is used.
For best results, use Dentronix DMP-US+ Cleaner solutions.
• Do not place objects directly on bottom of the tank. They may
block cavitation, cause heat buildup in the transducer and
premature failure. Use accessory baskets, cassette racks or
beaker positioning cover to hold items.
• Do not use flammable liquids with Dentronix units.
• Do not restrict air flow. Provide adequate ventilation.
• Do not use acids in the stainless steel tank.
• Do not subject unit to shock or impact.
• Do not immerse the unit in water.
• Keep unit covered to reduce aerosols.
• Unspecified or improper use of this product may impair
safety protection.
• This equipment generates, uses, and can radiate radio
frequency energy and if not installed and used in accordance
with the instruction manual, may cause interference to radio
communications. It has been tested and found to comply with
the limits for an ultrasonic cleaner pursuant to Subpart C of
Part 18 of FCC Rules, which are designed to provide reason-
able protection against such interference when operated in
accordance with these instructions. Operation of this equip-
ment in a manner inconsistent with this manual is likely to
cause interference in which case the user, at his own expense,
will be required to take whatever measures may be required
to correct the interference.
VIII. Order Information
A. Units
Cat. No. Description Contents
DDUS60-115 Unit (115V, 50/60Hz) 1
DDUS60-230CE Unit (230V, 50/60Hz) 1
DDUS60R-115 Unit (115V, 50/60Hz) 1
DDUS60R-230CE Unit (230V, 50/60Hz) 1
B. Accessories:
DDUS60K Large hands-free FingerGuard
Instrument Basket
1
DDUS60W Twin hands-free FingerGuard
Instrument Basket
1
DDUS60P Dentronix Plier Stand Rack 1
DDUS60S Cassette Rack for Hu-Friedy IMS/
Thompson cassettes
1
DDUS60C Two-Beaker Positioning Cover 1
DDUS60I Basket Section Inserts 2
DDUS60F Replacement Drain Filters 3
DDUS60H Drain Hose 1
DDUS60B 600ml Borosilicate Beaker with
Cover and Rubber Ring
1
C. Ultrasonic Cleaning Solutions:
DMP-US+ Super Concentrate General Purpose Ultrasonic
Cleaning Solution Concentrate in 8oz. (236ml)
Meter Dose Dispensing Bottle
D-CR2 Ultrasonic Cement Remover Concentrate in 8oz.
(236ml) Meter Dose Dispensing Bottle
IX. Unit Specifications
DDUS60 Countertop model
Tank capacity 4.8 gallons (18.3 liters)
Use capacity 4.0 gallons (15.2 liters)
Power 400 watts max
Operating frequency 40 kHz
100-115V Fuse T8A/250V, 5x20mm
230-240V Fuse T4A/250V, 5x20mm
Tank dimensions 14.0" x 9.0" x 8.75"
(35.6 x 22.9 x 22.2cm)
Overall dimensions 19.0" x 12.25" x 14.0"
(31.1 x 48.3 x 35.6cm)