12
5. Replacing the hose and pressure regulator
Replace your propane gas hose every four years. This is a national advice. Pressure regulators can go for five
years. Always check the unit after replacing the pressure regulator and gas hose for gas leaks.
How to check your build up burner on gas leaks:
-
Open the gas bottle but do not turn on the burner!
-
Make a spray of half water and half of detergent, and spray this liquid on each connection and the hose.
If there is a gas leak in the connection or the hose there will be air bubbles arise.
-
If bubbles are visible, immediately shut off the gas. Buy a new hose or regulator.
-
If the problem persist, please contact a qualified gas engineer.
Replace the hose or pressure regulator so that they are mounted on the exact same way. In the Netherlands, a
30 mbar pressure regulator should be placed. The hose must not be longer that 2.5 meters.
When in doubt, always consult a qualified gas engineer.
6. Replacing the battery for the piezo ignitior
The build up burner features a piezo ignition that runs on one
AAA battery. It may happen that after repeated use, the
battery runs out. The battery can be replaced as follows :
-
Make sure the model, ceramic logs and lava rocks are
completely cooled down.
-
Make sure the build up burner is no longer connected to
the gas cylinder.
-
The left knob on the control panel, there is the ignitor, the
battery is in the black capsule.
-
You can now rotate the black ignition and open the battery
as instructed in the sites of inflammation
-
The old battery should be returned to a collection point.
7. Moving the unit
It is advisable to minimize the move of the build up burner. With every move you risk to damage the build in
burner. If you still want to move the unit, make sure that the burner is locked off from the gas bottle. The new
location for build up burner needs to be clean, flat and hardened again.
8. Installing the cover
With eacht Cosiburner build up a protective cover is supplied. The protective cover protects your burner
against weather influences. It is always advised to use the cover. Place the cover only when the build up burner
has completely cooled down. If you place the cover immediately after using the cover will damage and even
catch fire.
9.
Placing the Glasset (optional accessory)
Cosi sell separately as an accessory square and rectangular glass sets. A Glasset is placed around the burner and
protects the flame from the wind. In addition, this Glasset protection from prying hands of children and pets.
Note: the Glasset is hot, do not touch the Glasset during burning. Wait at least an hour before lifting or moving
the Glasset.
