CB081A-CB143A / CBE103A-CBE143A Series
Installation and Operation Instruction Manual
16
www.coastair-ac.com
Owner’s Manual -
Room Air Conditioner with R-410A BG-P/BG-M/BGE-M Series
15
Heat Controller
Room Air Conditioner with R-410A
Owner’s Manual
16
INSTALLATION INSTRUCTIONS
W a l l S l e e v e B r a n d s :
# 9 W h i t e W e s t i n g h o u s e o r F r i g i d a i r e
( 2 2 D e e p )
2 . P l a c e ( 2 ) 1 x 1 x 1 4 s e a l s a g a i n s t e a c h s i d e .
3 . G e n t l y s l i d e u n i t i n a n d c h e c k i f a m o u n t e x t e n d -
i n g f r o m t h e s l e e v e i s s u f f i c i e n t o n c e t h e t r i m
f r a m e i s a t t a c h e d .
4 . I f p o s i t i o n i s O k , r e m o v e u n i t a n d p r o c e e d t o
t h e n e x t s t e p . I f n o t g o t o s t e p 8 .
5 . A t t a c h ( 1 ) 1 x 1 x 1 5 l o n g s e a l t o t h e l e f t a n d
r i g h t s i d e s o f t h e s l e e v e .
6 . C u t ( 1 ) 1 x 1 x 2 5 l o n g s e a l t o 1 4 l o n g a n d
a t t a c h i t v e r t i c a l l y t o t h e r e a r g r i l l 4 . 5 f r o m
t h e l e f t s i d e , r e p e a t a n d a t t a c h 4 f r o m t h e r i g h t
s i d e .
7 . A t t a c h ( 1 ) 1 x 1 x 2 5 l o n g s e a l i n t h e c e n t e r a t
t h e t o p o f t h e s l e e v e . R e m o v e t h e b a c k i n g p a p e r
a n d p r e s s i n t o p o s i t i o n . P r o c e e d t o s t e p 1 4 .
U s e t h e s e n e x t s t e p s i f t h e u n i t r e q u i r e s e x t r a
e x t e n s i o n i n t o t h e r o o m .
8 . A t t a c h 1 x x 1 4 l o n g s e a l o v e r t h e s o l i d
v e r t i c a l p o r t i o n o f t h e r e a r g r i l l e .
9 . A t t a c h ( 2 ) 4 x 3 x 1 f o a m b l o c k s w i t h t h e
s l o t o v e r l a p p i n g t h e s e a l a b o v e .
1 0 . I n s t a l l t h e d i v i d e r i n t o t h e s l o t s o f t h e f o a m
b l o c k s . Yo u m a y n e e d t o t r i m t h e l e n g t h t o s i z e .
1 1 . R e p e a t s t e p s 8 - 1 0 f o r t h e o t h e r v e r t i c a l s h o w n
p o r t i o n o f t h e g r i l l e a s s h o w n i n t h e p i c t u r e .
1 2 . A t t a c h ( 2 ) 1 x 1 x 1 4 s e a l s a l o n g t h e s i d e s
o f t h e s l e e v e a g a i n m a k i n g s u r e a l l s e a l s a r e
f l u s h .
1 3 . C u t t h e 1 x 1 x 2 5 s e a l t o f i t t h e t o p o f t h e
s l e e v e . T h e p i e c e s m u s t b e f i t t e d f l u s h t o t h e
e d g e o f t h e d i v i d e r.
1 4 . C e n t e r u n i t a n d g e n t l y s l i d e u n i t i n t o s l e e v e .
1 5 . B e f o r e s l i d i n g a l l - t h e - w a y b a c k , r e m o v e 1 s t
s c r e w f r o m f r o n t o n l e f t s i d e o f u n i t .
1 6 . R e m o v e t h e p l a s t i c w a s h e r f r o m t h e s c r e w.
1 7 . S c r e w a n d a t t a c h t h e o t h e r e n d o f t h e g r o u n d
w i r e t o t h e u n i t a s s h o w n i n p i c t u r e . M a k e s u r e
t h a t t h e t o o t h e d w a s h e r i s a g a i n s t t h e c a b i n e t .
1 8 . S l i d e t h e u n i t c o m p l e t e l y t o t h e r e a r t o e n s u r e
a g o o d s e a l , m a k i n g s u r e t h e g r o u n d w i r e d o e s
n o t b e c o m e t a n g l e d .
1 9 . S e a l & F r a m e t h e u n i t a s d e s c r i b e d o n p a g e 1 7 .
2 0
.
I f y o u h a v e d i f f i c u l t y w i t h m o u n t i n g t h e g r i l l t o
t h e s l e e v e , f o l l o w t h e i n s t r u c t i o n s f o r d i r e c t
m o u n t i n g o n P a g e 1 6 .
B e c a u s e o f t h e i n c r e a s e d u n i t d e p t h , f i r s t t r y
d r y f i t t i n g u s i n g t h e m e t h o d d e s c r i b e d b e l o w :
1
/
2
1
/
2
1
/
2
1
/
2
3
/
4
3
/
4
3
/
4
3
/
4
1
/
2
1
/
2
1 .
6
7
11
8
1 0
1 2
9
1 3
R e m o v e e x i s t i n g r e a r g r i l l e a s s h o w n o n P a g e
6 o f t h i s m a n u a l a n d r e p l a c e w i t h p r o v i d e d
l o u v e r e d r e a r p a n e l . I n s t a l l a s s h o w n h e r e .
N O T E :
Y o u m a y n e e d t o d r i l l h o l e s i n f l a n g e
o f e x i s t i n g s l e e v e t o m a t c h n e w r e a r g r i l l e .
5
6
4
4
4
4
3
8
3
8
4
4
1 5
#9 White Westinghouse or Frigidaire
- (22” Deep)
1. Remove existing rear grille as shown on Page 6 of this
manual and replace with provided louvered rear panel.
Install as shown here.
NOTE:
You may need to drill holes in flange of existing
sleeve to match new rear grille.
Because of the increased unit depth, first try dry
fitting using the method described below:
2. Place (2) 1” x 1-1/2” x 14” seals against each side.
3. Gently slide unit in and check if amount extending from
the sleeve is sufficient once the trim frame is attached.
4. If position is Ok, remove unit and proceed to the next
step. If not go to step 8.
5. Attach (1) 1” x 1-1/2” x 15” long seal to the left and right
sides of the sleeve.
6. Cut (1) 1” x 1-1/2” x 25” long seal to 14” long and attach
it vertically to the rear grill 4.5 from the left side ,repeat
and attach 4 from the right side.
7. Attach(1) 1” x 1-1/2” x 25” long seal in the center at the
top of the sleeve. Remove the backing paper and press
into position. Proceed to step 14. Use these next steps if
the unit requires extra extension into the room.
8. Attach 1” x 3/4” x 14” long seal over the solid vertical
portion of the rear grille.
9. Attach (2) 4-3/4” x 3-3/4” x 1-3/4” foam blocks with the
slot overlapping the seal above.
10. Install the divider into the slots of the foam blocks. You
may need to trim the length to size.
11. Repeat steps 8-10 for the other vertical shown
portion of the grille as shown in the picture.
12. Attach (2) 1” x 1-1/2” x 14” seals along the sides of the
sleeve again making sure all seals are flush.
13. Cut the 1” x 1-1/2” x 25” seal to fit the top of the sleeve.
The pieces must be fitted flush to the edge of the divider.
14. Center unit and gently slide unit into sleeve.
15. Before sliding all-the-way back, remove 1st screw from
front on left side of unit.
16. Remove the plastic washer from the screw.
17. Screw and attach the other end of the ground wire to
the unit as shown in picture. Make sure that the toothed
washer is against the cabinet.
18. Slide the unit completely to the rear to ensure a good
seal, making sure the ground wire does not become
tangled.
19. Seal & Frame the unit as described on page 17.
20. If you have difficulty with mounting the grill to the sleeve,
follow the instructions for direct mounting on Page 16.
