Coffing Hoists EC Series, Руководство по эксплуатации, техническому обслуживанию и каталог запасных частей

Страница: 24 / 48

24
P/N EC680-7 April 2017
Order # 5041558-0 & 5041679-0
SECTION VIII
REPAIR PARTS LIST
Using “Commercial” or other manufacturer’s parts to repair the
COFFING Hoists may cause load loss.
TO AVOID INJURY
Use only COFFING supplied replacement parts. Parts may
look alike but COFFING parts are made of specific materials
or processed to achieve specific properties
ORDERING INSTRUCTIONS
The following information must accompany all correspondence
orders for replacement parts:
1. Hoist Model Number from identification plate.
2. Serial number of the hoist from identification plate.
3. Voltage, phase, hertz from the identification plate.
4. Length of lift.
5. Part number of part from parts list.
6. Number of parts required.
7. Part name from parts list.
NOTE: When ordering replacement parts, it is recommended
that consideration be given to the need for also ordering such
items as gaskets, fasteners, insulators, etc. These items may be
damaged or lost during disassembly, or just unfit for future use
because of deterioration from age or service.
8-1. GENERAL
The following exploded drawings provide a complete list of parts
used in the standard EC hoist models (shown in Table 1-1 . page 3).
Since several different models of hoists are covered by this manual,
differences may be noted between the appearance of your hoist
part and the reference illustration. If this is the case, the parts list will
show several different part numbers with sufficient information to
allow the selection of the correct part number.
8-2. HOW TO USE THE PARTS LIST
a. The parts list consists of four columns as follows:
1. Index Number
2. Usage Code — This column may contain a code relating lo
the model numbers of, or other data relating to the hoist in
which the part is used. Usage codes are as follows:
A. Single Phase Hoists (Single Speed)
B. Three Phase Hoists (Single Speed)
C. Three Phase Hoists (Two Speed)
D. Hoists with 1/4 in. Load Chain (Models EC-0516, EC-
0532, EC-0564, EC-1009, EC-1016, EC-1032, EC-2004
and EC-2008))
E. Hoists with 9/32 in. Load Chain (Models EC-2012, EC-
2016, EC-4006, EC-4008 and EC-6005)
F. Single Chain Hoists (Models EC-0516, EC-0532, EC-
0564, EC-1009, EC-1016, EC-1032)
G. Double Chain Hoists (Models EC-2004, EC-2008, EC-
4006, EC-4008)
H. Single Chain Hoists (Models EC-2012, EC-2016)
J. Triple Chain Hoists (Model EC-6005)
3. Part Number
4. In addition to basic part name. This column contains
descriptions which are essential for choosing the correct
part number when more than one is listed.
b. How to determine proper part number:
1. Locate the index number in the corresponding figure
of the parts list.
2. If only one part number is listed for the index number,
that part number should be ordered.
3. If more than one usage code and part number is listed
for that index number. Choose the correct usage code by
comparing the model number or electrical characteristics
of your hoist with the usage codes above.
EXAMPLE A
Index No. Usage Code Part No. Part Name
6 E 35J1 Transmission Housing
D 35J2 Transmission Housing
4. If more than one part number is listed with the same usage
code, the information under “part name” will determine the
correct part number. This is also the case if no usage code
is listed and more than one part number is listed for the
index number.
EXAMPLE B
Index No. Usage Code Part No. Part Name
4 B 821J432
Transformer
(Pri 230/460V, Sec. 24V)
B 821J431
Transformer
(Pri 230/460V, Sec.115V)
8-3. HOW TO FIND YOUR HOIST MODEL
NUMBER AND SERIAL NUMBER
When ordering parts or requesting information concerning your EC
hoist, always include the hoist model number and serial number. A
product label with this information is located near the power cord
entry hole on the side of the hoist as shown below. There is also
a serial number label on the hoist near the electric brake and limit
switch under the brake cover.
See illustration below.
When ordering motor parts, please provide complete motor
nameplate data, including motor “ref.” number or model number.
NOTE
Repair parts are available only from Coffing distributors or authorized
repair facilities. It is recommended that repair part orders be directed
to the authorized repair facility nearest you.
IDENTIFICATION PLATE