Club Car 2005 FE290, Дополнение к руководству по обслуживанию

Страница: 41 / 168

TROUBLESHOOTING AND ELECTRICAL SYSTEM Test Procedures
2005 FE290 Gasoline Vehicle Maintenance and Service Supplement Page 11-25
11
A
4. If not previously tested, test the spark plug cap separately from the secondary coil.
4.1. Remove the rubber gasket (1) on the plug cap (2) by rolling back the gasket onto the spark plug wire
(3) (Figure 11-20, Page 11-23) .
4.2. Remove the cap from the wire by turning the cap counterclockwise three or four revolutions while
gently pulling it off the wire (Figure 11-21, Page 11-23) .
4.3. Using a multimeter set to 20k (ohms), place the red (+) probe of the multimeter into the end of the
spark plug cap that normally connects to the spark plug and place the black (–) probe into the end
of the cap with the internal screw (Figure 11-22, Page 11-23) . If the multimeter does not indicate
continuity, the cap has failed and must be replaced. Proceed to the next step with the spark plug
cap still removed.
5. Test the secondary coil separately from the spark plug cap.
5.1. Using a multimeter set to 20k (ohms), place the red (+) probe of the multimeter into the end of the
spark plug wire and place the black (–) probe on the core (2) (Figure 11-26, Page 11-26) . If the
resistance is between 6.0k - 11.0k (ohms), the secondary coil is within acceptable limits. If the resis-
tance is not between 6.0k - 11.0k (ohms), the ignition coil has failed and must be replaced.
6. If the preceding tests indicate that the ignition coil resistance readings are within acceptable ranges, but
the coil fails to function properly, replace the ignition coil and cap.
Figure 11-24 Primary Coil Resistance – Bench Test Figure 11-25 Secondary Coil and Cap
Resistance – Bench Test
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
1000
OFF
WAVETEK 5XL
V
V
V
A
! !
COM 200nA
MAX
1000 ---
750V
FUSED
2
1
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
1000
OFF
WAVETEK 5XL
V
V
V
A
!
!
COM 200nA
MAX
1000 ---
750V
FUSED
2
3
SECONDARY COIL