Club Car 2001 DS PowerDrive Plus, Руководство пользователя

Страница: 25 / 48

Periodic Lubrication Schedule
2001 DS Golf Car Electric Vehicle Owner’s Manual 23
PERIODIC LUBRICATION SCHEDULE
*See Figure 11, Page 24.
Monthly Service by Owner
or Trained Technician,
Continued:
Wiper Switch
See Figure 12, Page 24 to determine
applicability. Check for cracks or other damage; make sure switch
is securely fastened to frame. Check movable contact
for correct operation.
General Vehicle
Wash battery compartment and underside of vehicle.
Dispose of waste water properly.
Semi-annual Service by
Trained Technician Only
(Every 50 hours of opera-
tion or 100 rounds of golf)
Brake System
Check brake shoes; replace if necessary. See Sec-
tion 6 of the maintenance and service manual.
Lubricate brake slides per Lubrication Schedule. See Sec-
tion 6 of the maintenance and service manual.
Check brake cables for damage; replace as required.
Electrical Wiring and Connections Check for tightness and damage.
Forward/Reverse Switch
Check condition of contacts and wire connections;
Make sure connections are tight.
Front Wheel Alignment and Camber
Check and adjust as required. See Section 7 of the
maintenance and service manual.
Motor Controller Output Regulator (MCOR)
See Figure 13, Page 24 to determine
applicability.
Check for loose hardware, cracks or other damage.
Annual Service by Trained
technician Only (Every 100
hours of operation or 200
rounds of golf)
Batteries
If batteries are not performing as expected, refer to the
maintenance and service supplement, Section 13 –
Batteries.
• IF ANY PROBLEMS ARE FOUND, DO NOT OPERATE THE VEHICLE UNTIL REPAIRS ARE
MADE. FAILURE TO MAKE NECESSARY REPAIRS COULD RESULT IN FIRE, PROPERTY
DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.
PERIODIC LUBRICATION SCHEDULE
REGULAR INTERVAL SERVICE PLACE* RECOMMENDED LUBRICANT
Semi-Annually by Owner
or Trained Technician
(Every 50 hours of opera-
tion or every 100 rounds of
golf)
Brake pedal shaft bearings 1. Dry Moly Lube – Club Car Part No. 1012151
Brake Linkage and Pivots 2. Dry Moly Lube – Club Car Part No. 1012151
Accelerator push rod pivots and mounts 3. Dry Moly Lube – Club Car Part No. 1012151
Charger Receptacle (all vehicles)
Forward/Reverse switch contacts
(V-Glide and System 48 only)
4. WD 40
Brake Slides 5. Dry Moly Lube – Club Car Part No. 1012151
Front Suspension (5 fittings) 6. Chassis Lube – EP NLGI Grade 2
Periodic Lubrication Schedule continued on next page...
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL SERVICE
WARNING