®
Outdoor Patio Heater Model No. 235000
Troubleshooting
If the problem is:
And this condition exists:
Then do this
Pilot won’t light
Note: Heater operates at reduced efficiency below 40ºF (5ºC).
Tank valve is closed
Open valve
Blockage in orifice or pilot tube
Clean or replace orifice or pilot tube, visit www.bluerhino.com for
instructions.
Air in gas line
Open gas line and bleed it (pressing control knob in) for not more
than 1 - 2 minutes or until you smell gas
Low gas pressure with tank valve fully open
Turn tank valve “OFF” and replace tank
Igniter fails
Use match to light pilot; obtain new igniter and replace
Pilot won’t stay lit
Dirt built up around pilot
Clean dirt from around pilot
Connection between gas valve and pilot assembly is loose
Tighten connection and perform leak check
Thermocouple is not operating correctly
Replace thermocouple
Burner won’t light
Gas pressure is low
Turn tank valve “OFF” and replace tank
Blockage in orifice
Clear blockage
Control knob is not in “ON” position
Turn control knob to “ON”
Burner flame is low
Gas pressure is low
Turn tank valve “OFF” and replace tan
Outdoor temperature is less than 40ºF and tank is less than 1/4
full
Use a full tank
Supply hose is bent or kinked
Straighten hose
Control knob fully “ON”
Check burner and orifices for blockage
Emitter glows uneven
Note: Bottom 1” of emitter normally does NOT glow.
Gas pressure is low
Turn tank valvue “OFF” and replace tank
Base is not on a level surface
Place heater on a level surface
Heater is level
Clean burner
Carbon build-up
Dirt or film on reflector and emitter
Clean reflector and emitter
Thick black smoke
Blockage in burner
Remove blockage and clean burner inside and outside
For more assistance please visit us online at www.bluerhino.com or call 1.800.762.1142 for immediate assistance.
Specifications
Certifications:
CSA International Requirement 5.90
Canadian National Standard CAN1-2.23-M82
Rating:
Maximum 40,000 BTU/hr. input
Heat Range:
Up to 20 foot diameter
Fuel:
Liquid Propane Gas (LP)
Tank Size:
Nominal 20 lb / 5 Gallon
Inlet gas supply pressure:
Maximum – 150 PSI
Minimum – 5 PSI
Manifold Pressure:
11.00 in. W.C.
Engine:
IPP E8
Safety Features:
100% Burner shut-off
Tilt Switch
Manufacturer:
Blue Rhino Global Sourcing, Inc
Made In:
China
Optional Accessories
Wheel Kit
For easier portability.
Patio Heater Cover
Helps protect your heater from insects and the elements.
Please call your local supplier for more information.
