CAUTION:
Used without the safety alert symbol indicates potentially
hazardous situation which, if not avoided, may result in property damage.
RISK OF UNSAFE OPERATION.
When using tools or equipment, basic
safety precautions should always be followed to reduce the risk of personal
injury. Improper operation, maintenance or modification of tools or
equipment could result in serious injury and property damage. There are
certain applications for which tools and equipment are designed. Black &
Decker strongly recommends that this product NOT be modified and/or
used for any application other than for which it was designed. Read and
understand all warnings and operating instructions before using any tool
or equipment.
SAVE THESE INSTRUCTIONS
THIS MANUAL CONTAINS IMPORTANT SAFETY AND OPERATING
INSTRUCTIONS FOR THE BATTERY BOOSTER MODEL BB7B.
WARNING: TO REDUCE THE RISK OF INJURY:
• Follow these instructions and those published by the battery
manufacturer and manufacturer of any equipment you intend to use with
this unit. Review cautionary markings on these products and on engine.
IMPORTANT SAFETY INSTRUCTIONS
WARNING:
This product or its power cord contains lead, a chemical
known to the State of California to cause cancer and birth defect or other
reproductive harm. Wash hands after handling.
WARNING: BURST HAZARD:
Do not use the unit for charging dry-cell
batteries that are commonly used with home appliances. These batteries
may burst and cause injury to persons and damage property. Use the unit
for charging/boosting a LEAD-ACID battery only. It is not intended to
supply power to a low-voltage electrical system other than in a starter-
motor application.
WARNING: SHOCK HAZARD:
• An extension cord should not be used unless absolutely necessary. If
extension cord must be used, make sure that:
a) the pins of extension cord are the same number, size and shape as those
in the battery booster,
b) the extension cord is properly wired and in good electrical condition,
c) the wire size is large enough for the AC rating of the charger as indicated
in the table above.
• Do not operate unit with damaged cord or plug; or if the unit has received
a sharp blow, been dropped, or otherwise damaged in any way. Do not
disassemble the unit; take it to a qualified service technician when service
or repair is required. Incorrect reassembly may result in a risk of electric
shock or fire, and will void warranty.
4
3
• Use of an attachment not supplied, recommended or sold by manufacturer
specifically for use with this unit may result in a risk of electrical shock and
injury to persons.
• NEVER submerge this unit in water; do not expose it to rain, snow or use
when wet.
• To reduce risk of electric shock, disconnect the unit from any power
source before attempting maintenance or cleaning. Turning off controls
without disconnecting will not reduce this risk.
WARNING: RISK OF EXPLOSIVE GASES
• Working in the vicinity of a lead acid battery is dangerous. Batteries
generate explosive gases during normal battery operation. For this reason,
it is of the utmost importance that each time before using the battery
booster you read this manual and follow instructions exactly.
• To reduce the risk of battery explosion, follow these instructions and
those published by the battery manufacturer and manufacturer of any
equipment you intend to use in the vicinity of the battery. Review
cautionary markings on these products and on the engine.
WARNING:
TO REDUCE THE RISK OF INJURY, THIS UNIT SHOULD
ONLY BE OPERATED BY ADULTS; IT IS NOT FOR USE BY CHILDREN.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:
• Pull cord by plug rather than cord when disconnecting the 120 Volt AC
Charging Adapter from the unit and when disconnecting the Simple Start
™
from the vehicle’s 12 Volt DC accessory outlet.
• NEVER ATTEMPT TO JUMP-START OR CHARGE A FROZEN BATTERY.
• When using this unit to boost/start a vehicle, use only the built-in 12 Volt
DC Vehicle Adapter. The 12 Volt DC Outlet is strictly for use as an
accessory outlet.
• To recharge this unit, use only the supplied AC Charging Adapter or the
built-in 12 Volt DC Adapter Plug.
• Vehicles that have on-board computerized systems may be damaged if
vehicle battery is jump-started. Before jump-starting, read the vehicle’s
owner’s manual to confirm that external-starting assistance is suitable.
• Never insert a vehicle cigarette lighter into the unit’s 12 Volt DC
Accessory Outlet.
• 12 volts are present on the 12 volt plug end when the receptacle door is
open. To avoid damage of the product, store the plug in the compartment
after use.
• When storing the unit, turn the unit off and store the 12 Volt Plug in
the compartment.
• Have plenty of fresh water and soap nearby in case battery acid contacts skin.
• If battery acid contacts skin or clothing, wash immediately with soap and
water for at least 10 minutes and get medical attention immediately.
BB7B_Manual EN_082406 8/24/06 10:14 AM Page 3