Barbeques Galore Turbo STS, Инструкция по эксплуатации

Страница: 4 / 24

!
Only use the regulator and hose assembly supplied with
your gas grill. Replacement regulators and hose assem-
blies must be those specified by manufacture.
! Have your LP gas tank filled by a reputable propane gas
dealer and visually inspected and re-qualified at each fill-
ing.
! Never fill the gas tank beyond 80% full. Have your
propane gas dealer check the release valve after every fill-
ing to ensure that it remains free of defects.
! Always keep LP gas tanks in an upright position.
! Do not store (or use) gasoline or other flammable vapors
and liquids in the vicinity of this gas grill.
! An LP gas tank that is not connected for use must NOT be
stored on bottom shelf or in the vicinity of this or any other
gas grill.
!
Do not subject the LP gas tank to excessive heat.
!
Never store an LP gas tank indoors. If you store your gas
grill in the garage or other indoor location, always discon-
nect the LP gas tank first and store it safely outside and
out of reach of children.
!
LP gas tanks must be stored outdoors in a well-ventilated
area. Disconnected LP gas tanks must not be stored in a
building, garage or any other enclosed area.
!
When your gas grill is not in use the gas must be turned
off at the LP gas tank.
!
The regulator and hose assembly must be inspected
before each use of the grill. If there is excessive abrasion
or wear or if the hose is cut, it must be replaced prior to
the grill being used again.
! Keep the gas regulator hose away from hot grill surfaces
and dripping grease. Avoid unnecessary twisting of hose.
Visually inspect hose prior to each use for cuts, cracks,
excessive wear or other damage. If the hose appears
damaged do not use the gas grill. Call our service center
at
1-800-752-3085 .
! Never light your gas grill with the lid closed or before
checking to insure the burner tubes are fully seated over
the gas valve orifices.
! Never allow children to operate your grill. Do not allow
children to play near your grill.
n
WARNING
A strong gas smell, or the hissing sound of gas indicates a
serious problem with your gas grill or the LP gas tank. Failure
to immediately follow the steps listed below could result in a
fire or explosion that could cause serious bodily injury, death,
or property damage.
!
Shut off gas supply to the grill.
! Turn the Control Knobs to the OFF position.
! Open grill lid.
! Get away from the LP gas tank.
! Do not try to fix the problem yourself..
!
If odor continues or you have a fire you cannot extinguish,
call your fire department.
Do not call near the LP gas tank because your telephone is
an electrical device and could create a spark resulting in fire
and/or explosion.
NOTE: The normal flow of gas through the regulator and
hose assembly can create a humming noise. A low volume of
noise is perfectly normal and will not interfere with operation
of the grill. If humming noise is loud and excessive you may
need to purge air from the gas line or reset the regulator
excess gas flow device. This purging procedure should be
done every time a new LP gas tank is connected to your grill.
For help call the Customer Service Helpline for assistance.
The barbecue must be isolated from the gas supply pip-
ing system by closing its individual manual shut-off valve dur-
ing any pressure testing of the gas supply piping system at
test pressures
equal to or less than ½ psi (3.5 kPa)
The units are supplied from the factory equipped for use
with natural gas and includes a natural gas regulator. If oper-
ation with propane gas is desired, simply follow the instruc-
tions found on
page 4 of this manual. In addition, a propane
gas regulator MUST be installed in the gas supply line from
the propane gas tank.
Please remember to check all gas connections for leaks
after the piping is completed. Follow the procedure found on
page 1 , under the heading "CAUTION: LEAK CHECKING."
CAUTION: ELECTRICAL WARNING
If your grill incorporates electrical components they must
be installed in accordance with local codes or in the absence
of local codes, with the
National Electrical Code,
ANSI/NFPA No.70-1987 .
The electric cord for the optional rotisserie motor is
equipped with a three-prong 115v plug, and must be used
with a grounded outlet. If it is not designed for a three wire
plug, you must obtain an adapter and properly ground it
before using the rotisserie. Do not cut or remove the ground-
ing prong from the plug.
KEEP ANY ELECTRICAL SUPPLY CORD AND THE FUEL
SUPPLY HOSE AWAY FROM ANY HEATED SURFACE.
Failure to comply with these instructions may result in
serious bodily injury.
The LP gas pressure regulator and hose assembly sup-
plied with this unit must be used without alteration. If this
assembly needs to be replaced, use only the type specified by
Barbeques Galore for this appliance.
When connecting the LP gas regulator to the supply cylin-
der, please remember that the threaded fittings on the QCC-1
valve tightens clockwise (
Figure 1 ). This connection must be
tightened fully to prevent leakage.
I) If your Propane tank should ever require repainting use a
light colored paint to allow heat reflection. Never use a
dark color to repaint the Propane tank.
- 2 -