AquaCare AS90000, Руководство по установке и эксплуатации

Страница: 22 / 44

22 AquaCare: Installation
Preparing the AquaCare For First Use
When training with the AquaCare, powder could cause mess and damage to sensitive
equipment if the user is not accustomed to operating the machine. For first use, either
work near a sink or lay out a towel on the worksurface. Aim the handpiece nozzle into
the inlet of your evacuation unit. Always wear goggles when operating the AquaCare.
See INTRODUCTION: SAFETY WARNINGS, Pg 5.
A. Check that all of the INSTALLATION sections have been completed and the
INSTALLATION TEST has been successful.
B. Fit the dosing chamber with a sodium bicarbonate powder cartridge.
C. Make sure you are in full control of the handpiece.
D. Switch the On/Off selector to ON position.
E. Press the foot pedal fully down to the CUT position 3. You will hear the vibrator start
to operate. The nozzle will start to spray a mixture of air, fluid and powder.
F. Turn the Media volume dial, observing the spray. On a paper towel, you should see a
ring of white powder inside an outer ring of fluid. The Media volume range as shown
by the media gauge varies between:
Slightly under midway position - Low powder content, slow cutting/cleaning
Midway position - Medium powder content, cutting
Slightly above midway position - High powder content, very fast cutting
G. The powder needs to be purged whenever you replace a powder cartridge. The
MAINTENANCE: PURGING THE AQUACARE, Pg 33.
H. The AquaCare is now ready for use when required. Turn off the machine.
I. Always place the handpiece back in its holder after use.
The OPERATION section contains training procedures to get started, and
recommended settings for different uses.
If your observations do not match the results above, refer to the SERVICE section for
a full test procedure and troubleshooting tips. Alternatively, refer the problem to a
Velopex Representative or Authorised Distributor.
Use only original Velopex consumable products (powders, handpieces etc.). Other
makes may damage the AquaCare or negatively alter performance.