Troubleshooting Guide
Trouble
Probable Cause
Suggested Remedy
1. Hood does not operate when the switch is on.
1a. A fuse may be blown or a circuit tripped.
1a. Replace fuse or reset circuit breaker.
1b. Wiring is not connected properly.
1b. Turn off power to unit. Check that all wires are connected
2. Hood is operating, but air moves slower than normal.
2. Obstruction in the exhaust ducting.
2. Check for any obstructions in the ducting including filter.
3. Hood is making a rattling noise.
3a. Motor is loose.
3a. Turn off power to unit. Remove filter, check that all screws are
fully tightened.
3b. Duct connection is loose.
3b. Turn off power to unit. Check that duct connection is tight.
6728005 New 2-05
www.airkinglimited.com
LIMITED WARRANTY
All products manufactured by Air King Limited are warranted for one year from the date of purchase against defects in workmanship
and/or material. In addition, all ventilating/exhaust fans, heaters, combination fan lights and/or heaters, and range hoods are
guaranteed for five years from the date of purchase against defects in workmanship and/or material.
This warranty does not cover any labor or shipping costs or the cost of replacement components as part of routine maintenance
such as: range hood grease filters, charcoal filters or combination charcoal/grease filters; replacement light bulbs in range hoods
or bathroom fan/light/bulb heater combinations. As well, any damage or failure caused by abuse, misuse, abnormal usage, faulty
installation, or improper maintenance will not be covered by this warranty.
In order to make a claim on this warranty, you must be the original consumer of the product. You will be required to present to
Air King the original bill of sale showing: date of purchase, place of purchase and model purchased. Failure to meet these
requirements will void your warranty.
Air King will not be held responsible for any bodily injury or damages to personal property or real estate whether caused directly
or indirectly by the product. Some states and provinces do not allow the exclusion or limitation of incidental or consequential
damages and some states do not allow limitations on how long an implied warranty lasts, so these exclusions or limitations may
not apply to you. This warranty gives you specific legal rights and you may have other rights which vary from state to state and
province to province.
FOR PARTS OR TECHNICAL ASSISTANCE
Please call: 1-800-465-7300,
MONDAY THROUGH FRIDAY, BETWEEN THE HOURS OF 8 AM AND 4:00 PM EST.
PLEASE DO NOT RETURN PRODUCT TO PLACE OF PURCHASE.
Reference the type and style of product (located on label inside of the product) when you call.
For more information please visit our website: wwwairkinglimited.com
2.
Turn switches to the “OFF” position and restore power. Test that
the light and the fan are operating properly.
3.
If there is any vibration noise, check for the source and try to
tighten fasteners or adjust the tape to make a tighter connection
or seal.
Operation
Controls
Your Range Hood is equipped with two rotary switches with one
controlling the lighting and the other controlling the exhaust fan. The
light switch has three positions, HIGH ( ), LOW ( ), and OFF ( ).
The fan switch is an infinite speed control that can be adjusted to
your desired setting. Rotating the switch counter clockwise until you
hear a click will turn the hood off.
Maintenance
CAUTION:
MAKE SURE POWER IS SWITCHED OFF AT SERVICE
PANEL BEFORE SERVICING THE UNIT.
Filters
1.
Grease Filter - Included with your range hood is an aluminum
grease filter that should be washed in hot water with detergent
once a month. Reverse the instructions in the “Finishing the Installation”
section of the instructions to remove filter. If the grease filter becomes
damaged, replace with Air King Model GF-06 Grease Filter.
2.
Charcoal Odor Filter - If you have installed an optional charcoal
odor filter or a combination grease/charcoal filter, they cannot be
washed and must be discarded and replaced when they become
noticeably dirty, have stopped filtering the odors, or at least once
per year. Replace with Air King Model CF-06 Odor Filter.
Cleaning
CAUTION:
DO NOT USE GASOLINE, BENZINE, THINNER, HARSH
CLEANSERS, ETC., AS THEY MAY DAMAGE THE RANGE HOOD.
1.
Clean your range hood with a mild detergent, such as dishwashing
liquid, and dry with a soft cloth.
NEVER USE ANY ABRASIVE PADS
OR SCOURING POWDERS.
Completely dry before restoring power.
NEVER IMMERSE ELECTRICAL PARTS IN WATER.
2.
The fan assembly can be vacuumed when build up (dirt, lint, etc.)
accumulates over time. The fan is permanently lubricated and does
not require oiling.
4
Содержание QZ Series
Страница 16: ...www airkinglimited com 16 6728005 New 2 05...
