2 www.hotwater.com
TABLE OF CONTENTS
TABLE OF CONTENTS
2
SAFE INSTALLATION, USE AND SERVICE
3
GENERAL SAFETY
4
INTRODUCTION 6
Quali
fi
ed Installer Or Service Agency . . . . . . . . . . . . 6
Preparing For The Installation . . . . . . . . . . . . . . . . . . 6
INSTALLATION REQUIREMENTS FOR THE
COMMONWEALTH OF MASSACHUSETTS
7
TYPICAL INSTALLATION
9
Get To Know Your Water Heater - Gas Models
(List Referencing Figures 1-7). . . . . . . . . . . . . . . . . . 9
Replacement Parts And Deliming Products . . . . . . 10
Combo Heating Inlet And Outlet Side Taps. . . . . . . 10
Water Piping - Mixing Valve Usage . . . . . . . . . . . . . .11
Mixing
Valves
Water Heater Operation . . . . . . . . . . . . . . . . . . . . . 12
Electrical Requirements & Wiring Diagram . . . . . . . 13
SAFETY LOCKOUTS
14
High Limit Controls (TCO). . . . . . . . . . . . . . . . . . . . 14
Thermostat/Water
Temperature
Blower High Limit Switch
Blower Air Pressure Switch . . . . . . . . . . . . . . . . . . . 14
Flammable Vapor Sensor . . . . . . . . . . . . . . . . . . . . 14
LOCATING THE NEW WATER HEATER
15
Facts To Consider About The Location . . . . . . . . . . 15
Storage Of Flammable Liquids . . . . . . . . . . . . . . . . 15
Clearances
To
Combustibles
Floors With Carpeting
Clearance For Servicing
Insulation Blankets . . . . . . . . . . . . . . . . . . . . . . . . . 17
Air Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Uncon
fi
ned Space. . . . . . . . . . . . . . . . . . . . . . . . . . 17
Unusually Tight Construction . . . . . . . . . . . . . . . . . 17
Con
fi
ned Space. . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Direct Vent Appliances . . . . . . . . . . . . . . . . . . . . . . 18
Exhaust Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Fresh Air Openings For Con
fi
ned Spaces. . . . . . . . 18
Chemical Vapor Corrosion . . . . . . . . . . . . . . . . . . . 19
INSTALLING THE NEW WATER HEATER
20
Water Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Space Heating And Potable Water Systems . . . . . . 20
Combo Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
System
Requirements
Installation
Closed Water Systems . . . . . . . . . . . . . . . . . . . . . . 22
Thermal Expansion . . . . . . . . . . . . . . . . . . . . . . . . . 22
Temperature-Pressure Relief Valve. . . . . . . . . . . . . 23
T&P Valve Discharge Pipe Requirements:
Temperature-Pressure Relief Valve And Pipe Insulation
High Altitude Installation . . . . . . . . . . . . . . . . . . . . . 24
Gas Piping. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Sediment Traps/Dirt Leg . . . . . . . . . . . . . . . . . . . . . 25
Filling The Water Heater . . . . . . . . . . . . . . . . . . . . . 26
Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Termination Clearances Sidewall Power Vent. . . . . 27
Blower Assembly Installation. . . . . . . . . . . . . . . . . . 28
Installation Of Vent System . . . . . . . . . . . . . . . . . . . 28
Planning The Vent System . . . . . . . . . . . . . . . . . . . 28
High Ambient Temperature Installations . . . . . . . . . 28
Polypropylene Vent Systems . . . . . . . . . . . . . . . . . 29
Condensate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Exhaust Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Important Notes And Warnings
Venting
Terminations
And
Sizing
Vent Screen Installation
Calculating Equivalent Feet
Venting
Instructions
Vent Pipe Connection To Blower
Different Coupling Installations According To Vent Sizes
Blower Exhaust Direction . . . . . . . . . . . . . . . . . . . . 35
Vent Pipe Preparation . . . . . . . . . . . . . . . . . . . . . . . 35
Installation Checklist . . . . . . . . . . . . . . . . . . . . . . . . 38
LIGHTING INSTRUCTIONS
39
OPERATING THE TEMPERATURE
CONTROL SYSTEM
40
Gas Control Valve/Thermostat . . . . . . . . . . . . . . . . 41
FOR YOUR INFORMATION
42
Start Up Conditions . . . . . . . . . . . . . . . . . . . . . . . . . 42
Condensate
Thermal
Expansion
Closed Water Systems
Smoke/Odor
Strange
Sounds
Operational Conditions . . . . . . . . . . . . . . . . . . . . . . 42
Smelly
Water
“Air” In Hot-water Faucets . . . . . . . . . . . . . . . . . . . . 43
High Water Temperature Shut-off System. . . . . . . . 43
PERIODIC MAINTENANCE
44
General Upkeep . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Venting System Inspection . . . . . . . . . . . . . . . . . . . 44
Blower Maintenance . . . . . . . . . . . . . . . . . . . . . . . . 44
Cleaning The Blower. . . . . . . . . . . . . . . . . . . . . . . . 44
Burner Operation And Inspection . . . . . . . . . . . . . . 45
Combustion Chamber And Burner Cleaning . . . . . . 46
Housekeeping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Anode Rod Inspection. . . . . . . . . . . . . . . . . . . . . . . 46
Anode Rod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Removing
Anode
Rod:
Installing
Anode
Rod:
Temperature-Pressure Relief Valve Test . . . . . . . . . 47
Draining And Flushing . . . . . . . . . . . . . . . . . . . . . . . 48
To Drain The Water Heater Storage Tank:
To Flush The Water Heater Storage Tank:
LEAKAGE CHECKPOINTS
49
Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
REFERENCE PARTS LISTING
50
TROUBLESHOOTING GUIDELINES
52
Resetting
The
Heater
Control
. . . . . . . . . . . . . . . . . 54
TCO Resettable Lockout. . . . . . . . . . . . . . . . . . . . . 54
Lockouts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Soft
Lockout
Hard
Lockout
Ignition State And Timing . . . . . . . . . . . . . . . . . . . . 55
System Status And Error Codes . . . . . . . . . . . . . . . 55
LIMITED WARRANTY
58
Содержание GPVL Series
Страница 4: ...4 www hotwater com GENERAL SAFETY ...
