1
ELECTRIC
KEEP THIS MANUAL IN THE POCKET ON HEATER FOR FUTURE REFERENCE
WHENEVER MAINTENANCE ADJUSTMENT OR SERVICE IS REQUIRED.
PART NO. 184551-000
SUPERSEDES PART NO. 183795-000
GENERAL SAFETY INFORMATION
CAUTION
TEXT PRINTED OR OUTLINED IN RED CONTAINS INFORMATION RELATIVE
TO YOUR SAFETY. PLEASE READ THOROUGHLY BEFORE INSTALLING
AND USING THIS APPLIANCE.
EXTERNAL DAMAGE
Do not operate the water heater until it has been fully checked out
by a qualified service technician, if the water heater:
•
Has been exposed to fire or damage.
•
Produces steam or unusually hot water.
If the water heater has been subject to flooding, it must be replaced.
INSULATION BLANKETS
Insulation blankets available to the general public for external use on
electric water heaters are not necessary with A. O. Smith water heater.
The purpose of an insulation blanket is to reduce the standby heat loss
encountered with storage tank water heaters. Your A. O. Smith water
heater meets or exceeds the National Appliance Energy Conservation
Act standards with respect to insulation and standby loss requirements,
making an insulation blanket unnecessary.
WARNING
Should you choose to apply an insulation blanket to this heater, you
should follow these instructions (See Figure 1 for identification of
components mentioned below). Failure to follow these instructions can
result in fire, asphyxiation, serious personal injury or death.
•
Do not cover the temperature & pressure relief (T&P) valve.
•
Do not cover the instruction manual. Keep it on the side of the water
heater or nearby for future reference.
•
Do obtain new warning and instruction labels from A.O. Smith for
placement on the blanket directly over the existing labels.
EXTENDED NON-USE PERIODS
WARNING
Hydrogen gas can be produced in a hot water system served by this
heater that has not been used for a long period of time (generally two
weeks or more). HYDROGEN GAS IS EXTREMELY FLAMMABLE.
To
reduce the risk of injury under these conditions, it is recommended that
the hot water faucet be opened for several minutes at the kitchen sink
before using any electrical appliance connected to the hot water system.
If hydrogen is present, there will probably be an unusual sound such as
air escaping through the pipe as the water begins to flow. THERE
SHOULD BE NO SMOKING OR OPEN FLAME NEAR THE FAUCET AT THE
TIME IT IS OPEN.
RESIDENTIAL
ELECTRIC WATER HEATER
OWNER'S MANUAL
Thank you for buying this water heater from A.O. Smith Water Products
Company. We appreciate your confidence in our products.
Please read through this informative manual and pay special attention to
the following:
GENERAL SAFETY INFORMATION ............................ 1
GET TO KNOW YOUR WATER HEATER .................... 2
INSTALLATION ............................................................. 3
WIRING DIAGRAMS .................................................... 4
OPERATION .................................................................. 5
MAINTENANCE & TROUBLE SHOOTING .................. 6
INSTALLING POINT OF USE WATER HEATERS ..... 7-9
LEAKAGE CHECKPOINT ............................................ 10
WARRANTY ................................................................. 11
TABLE OF CONTENTS
A DIVISION OF A.O. SMITH CORPORATION
WWW.HOTWATER.COM
PRINTED IN THE U.S.A. 0903
