Yamaha XLT800 WaveRunner 2004, Owner'S/Operator'S Manual

Page: 62 / 136

3-5
E
EJU01346
Pre-operation checks
EJU13470
Pre-operation check list
Before operating this watercraft, perform the checks in the following check list. See the
accompanying text in this chapter for details on how to perform the checks.
WARNING
@
If any item in the pre-operation check list is not working properly, have it inspected
and repaired before operating the watercraft, otherwise an accident could occur.
@
NOTE:
@
Pre-operation checks should be made thoroughly each time the watercraft is used. This proce-
dure can be completed in a short time. It is worth the time spent to assure safety and reliability.
@
ITEM ROUTINE PAGE
Engine compartment Remove all seats and the front storage compartment to
ventilate the engine compartment. Check for fuel va-
pors and loose electrical connections.
3-6
Bilge Check for water and fuel and remove if necessary. 3-8
Stern drain plugs Check for proper installation. 3-8
Throttle lever Check that the throttle lever springs back smoothly. 3-11
Steering system Check for proper operation.
Check that the handlebars are securely locked.
3-11
Shift lever and reverse gate Check for proper operation. 3-12
QSTS Check for proper operation. 3-13
Fuel and oil Check fuel and oil levels and add if necessary.
Check the hoses and tanks for leakage.
3-7
Water separator Check for water and drain if necessary. 3-7
Battery Check electrolyte level and battery condition. 3-9
Hood Check that the hood is properly secured. 2-7
Front and rear seats Check that the seats are properly secured. 2-5, 2-6
Hull and deck Check the hull and deck for cracks or other damage. 3-6
Jet unit Check for debris and remove if necessary. 3-14
Fire extinguisher Check condition and replace if necessary. 3-10
Engine shut-off cord Check condition and replace if frayed or broken. 3-14
Switches Check the start switch, engine stop switch, and engine
shut-off switch for proper operation.
3-15
Cooling water pilot outlet Check that water is discharged while the engine is run-
ning and the watercraft is in the water.
3-15
Multifunction meter Check for warning indications and proper operation. 3-15
UF1F12.book Page 5 Friday, May 30, 2003 11:15 AM