Operation
32
EMU36381
First-time operation
EMU36391
Fill engine oil
The engine is shipped from the factory without
engine oil. If your dealer did not fill the oil, you
must fill it before starting the engine.
NOTICE:
Check that the engine is filled with oil be-
fore first-time operation to avoid severe
engine damage.
[ECM01781]
The engine is shipped with the following stick-
er, which should be removed after engine oil
is filled for the first time. For more information
on checking the engine oil level, see page 33.
EMU30174
Breaking in engine
Your new engine requires a period of break-in
to allow mating surfaces of moving parts to
wear in evenly. Correct break-in will help en-
sure proper performance and longer engine
life.
NOTICE:
Failure to follow the break-in
procedure could result in reduced engine
life or even severe engine damage.
[ECM00801]
EMU27085
Procedure for 4-stroke models
Your new engine requires a period of 10
hours break-in to allow mating surfaces of
moving parts to wear in evenly.
TIP:
Run the engine in the water, under load (in
gear with a propeller installed) as follows. For
10 hours for breaking in engine avoid extend-
ed idling, rough water and crowded areas.
1.
For the first hour of operation:
Run the engine at varying speeds up to
2000 r/min or approximately half throttle.
2.
For the second hour of operation:
Increase engine speed as much as nec-
essary to put the boat on plane (but avoid
full-throttle operation), then back off on
the throttle while keeping the boat at a
planing speed.
3.
Remaining 8 hours:
Run the engine at any speed. However,
avoid operating at full throttle for more
than 5 minutes at a time.
4.
After the first 10 hours:
Operate the engine normally.
EMU36400
Getting to know your boat
Different boats handle differently. Operate
cautiously while you learn how your boat han-
dles under different conditions and with differ-
ent trim angles (see page 43).
EMU36413
Checks before starting engine
WARNING
EWM01921
If any item in “Checks before starting en-
gine” is not working properly, have it in-
spected and repaired before operating the
outboard motor. Otherwise, an accident
could occur.
NOTICE
ECM00120
Do not start the engine out of water. Over-
heating and serious engine damage can
occur.
EMU36560
Fuel level
Be sure you have plenty of fuel for your trip. A
good rule is to use 1/3 of your fuel to get to the
destination, 1/3 to return, and to keep 1/3 as
ZMU01710
U60R3BE0.book Page 32 Thursday, May 2, 2013 8:59 AM
