1964 IMPALA
w/ AC
17
904064 REV A 7/22/08, 1964 IMPALA w/ AC GEN IV EVAP INSTR PG 17 OF 25
FINAL STEPS
INSTALL DUCT HOSES AS SHOWN IN FIGURE 18, PAGE 18.
ROUTE A/C WIRES THROUGH 5/8 GROMMET AS SHOWN ON FIGURE 16 ( 12 VOLT/ GROUND/ BINARY SWITCH/ HEATER VALVE)
PLUG THE CONTROL PANEL HARNESS INTO THE ECU MODULE ON SUB CASE AS SHOWN IN PAGE 18.
REINSTALL ALL PREVIOUSLY REMOVED ITEMS (BATTERY RADIO, SPEAKER, INSTRUMENT PANEL).
FILL RADIATOR WITH AT LEAST A 50/50 MIXTURE OF APPROVED ANTIFREEZE AND DISTILLED WATER.
IT IS THE OWNERS RESPONSIBILITY TO KEEP THE FREEZE PROTECTION AT THE PROPER LEVEL FOR THE CLIMATE IN WHICH THE
VEHICLE IS OPERATED. FAILURE TO FOLLOW ANTIFREEZE RECOMMENDATIONS WILL CAUSE HEATER CORE TO CORRODE
PREMATURELY AND POSSIBLY BURST IN AC MODE AND/OR FREEZING WEATHER, VOIDING YOUR WARRANTY.
DOUBLE CHECK ALL FITTINGS, BRACKETS AND BELTS FOR TIGHTNESS.
VINTAGE AIR RECOMMENDS THAT ALL AC SYSTEMS BE SERVICED BY A CERTIFIED AUTOMOTIVE AIR CONDITIONING
TECHNICIAN.
EVACUATE THE SYSTEM FOR A MINIMUM OF 45 MINUTES PRIOR TO CHARGING AND LEAK CHECK PRIOR TO SERVICING.
CHARGE THE SYSTEM TO THE CAPACITIES STATED ON THE INFORMATION PAGE (PAGE 4) OF THIS INSTRUCTION MANUEL.
INSTALL CONTROL PANEL ASM.
PLUG THE WIRING HARNESS INTO THE ECU MODULE ON SUB CASE AS SHOWN IN FIGURE 18, PAGE 18. (WIRE ACCORDING TO
WIRING DIAGRAM ON PAGE 20 & 21.)
NOTE:
CONTROL PANEL MUST BE CALIBRATED. (REFER TO CONTROL PANEL INSTRUCTIONS FOR CALIBRATION PROCEDURES.
GLOVE BOX INSTALLATION ( SEE FIGURE 17)
GLOVE BOX INSTALLATION
THE NEW GLOVE BOX IS MADE IN TWO (2) PIECES FOR EASY INSTALLATION.
INSERT BOTTOM HALF OF NEW GLOVE BOX, INTO GLOVE BOX OPENING AND POISTION IN PLACE.
INSERT TOP HALF OF GLOVE BOX AND FASTEN TO BOTTOM HALF USING (4) #6 x 3/8"
BLACK PAN HEAD PHILLIPS SCREWS (SEE FIGURE 17, BELOW).
INSTALL GLOVE BOX DOOR USING (3) OEM SCREWS THROUGH THE TINNERMAN NUTS.
INSTALL GLOVE BOX USING (2) OEM SCREWS SEE FIGURE 17a.
GLOVE BOX
TOP
624163
(4)#6 x 3/8
PH PAN HEAD
SCREWS
FIGURE 17
FIGURE 17a
OEM
SCREWS
OEM
SCREWS
TINNERMAN
NUTS
GLOVE BOX
BOTTOM
624164
FIGURE 16
GROMMET
FIREWALL
COVER
FIREWALL
CAP
