rapidly than if the machine is stored in a location
where temperatures are cool.
Battery electrolyte contains sulfuric acid which
is a deadly poison and causes severe burns.
•
Do not drink electrolyte and avoid contact
with skin, eyes or clothing. Wear safety
glasses to shield your eyes and rubber gloves
to protect your hands.
•
Fill the battery where clean water is always
available for flushing the skin.
2. Keep top of battery clean by washing periodically
with a brush dipped in ammonia or bicarbonate of
soda solution. Flush the top surface with water after
cleaning. Do not remove the fill cap while cleaning.
3. Battery cables must be tight on terminals to provide
good electrical contact.
4. If corrosion occurs at terminals, remove battery
cover, disconnect cables, negative (–) cable first and
scrape clamps and terminals separately. Reconnect
cables, positive (+) cable first and coat terminals
with petroleum jelly.
5. Check the electrolyte level every 50 operating hours
or, if machine is in storage, every 30 days.
6. Maintain cell level with distilled or demineralized
water. Do not fill cells above the bottom of the fill
ring inside each cell.
Drive System
Maintenance
Change Front Differential Oil
Four Wheel Drive Only
Service Interval:
Every 800 hours
1. Position vehicle on a level surface, stop engine,
engage parking brake and remove key from ignition
switch.
2. Clean area around drain plug on side of differential.
Place drain pan under drain plug.
Figure 54
1.
Front differential
3.
Drain plug
2.
Fill/check plug
3. Remove drain plug and let oil flow into drain pan.
Reinstall and tighten plug when oil stops draining.
4. Clean area around fill/check plug on side of
differential.
5. Remove fill/check plug and add 10W30 oil until oil
is up to hole.
6. Re–install fill/check plug.
Inspect Constant Velocity Boot
Four Wheel Drive Only
Service Interval:
Every 200 hours
Adjusting Shift Cables
Service Interval:
After the first 10 hours
Every 200 hours
1. Move shift lever to Neutral position.
2. Remove clevis pins securing shift cables to transaxle
shift arms.
45
Summary of Contents for 07362TC
Page 57: ...Schematics Hydraulic Schematic Rev A 57...
Page 58: ...Electrical Schematic Rev A 58...
Page 59: ......
