Sony HCD-D60, Service Manual

Page: 1 / 113

SERVICE MANUAL
COMPACT DISC DECK RECEIVER
Ver 1.1 2002.11
9-960-853-12
Sony Corporation
2002K0500-1 Home Audio Company
C
2002.11 Published by Sony Engineering Corporation
US Model
HCD-D60/RX70
Canadian Model
AEP Model
UK Model
HCD-RX70
E Model
HCD-GR7/GR7J
Australian Model
HCD-GR7
HCD-D60/GR7/GR7J/RX70
— Continued on next page —
HCD-D60/ GR7/GR7J/RX70 is the
tuner, deck, CD and amplifier section in
MHC-D60/ GR7/GR7J/RX70.
Model Name Using Similar Mechanism NEW
CD Mechanism Type CDM38-5BD29AL
Base Unit Name BU-5BD29AL
Optical Pick-up Name KSS-213D/Q-NP
Model Name Using Similar Mechanism HCD-H881
Tape Transport Mechanism Type TCM-220WR2
CD
Section
Tape deck
Section
SPECIFICATIONS
* Dolby noise reduction manufacrured
under license from Dolby Laboratories
Licensing corporation.
"DOLBY" and the double-D symbol
a
are trademarks of Dolby Laboratories
Licensing Corporation.
CD player section
System Compact disc and digital audio
system
Laser Semiconductor laser
(
λ
=780nm)
Emission duration: continuous
Laser output Max. 44.6
µ
W*
*This output is the value mea-
sured at a distance of 200 mm
from the objective lens surface
on the Optical Pick-up Block
with 7 mm aperture.
Frequency response 2 Hz - 20 kHz (
±
0.5 dB)
Wavelength 780-790 nm
Signal-to-noise ratio More than 90 dB
Dynamic range
More than 90 dB
CD OPTICAL DIGITAL OUT
(Square optical connector jack, rear panel)
(Except US model)
Wavelength
600 nm
Output Level –18 dBm
For the US model
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION:
With 8 ohm loads, both channels driven, from
70-20,000 Hz; rated 100 watts per channel
minimum RMS power, with no more than
0.9% total harmonic distortion from 250
milliwatts to rated output.
Amplifier section
Continuous RMS power output
Canadian model
100+100 watts
(8 ohms at 1 kHz, 5% THD)
AEP, German, East European, UK and CIS models
55+55 watts
(6 ohms at 1 kHz, 10% THD)
Other models 70+70 watts
(6 ohm sat 1 kHz, 10% THD)
Peak music power output (GR7/GR7J) :
1000 watts
Music power output
(AEP, German, East European, UK and CIS model):
95+95 watts
(6 ohms at 1kHz, 10% THD)
Inputs VIDEO/MD IN (phono jacks) :
voltage 250 mV,impedance 47
kilo ohms
MIX MIC (phone jack):
sensitivity 1 mV,
impedance 10 kilo ohms
Outputs VIDEO/MD OUT (phono jacks)
: voltage 250 mV impedance
1 kilo ohms
PHONES (stereo phone jack) :
accepts headphones of 8 ohms or
more.
SPEAKER : accepts impedance of
8 to 16 ohms (D60/RX70)
accepts impedance of 6 to 16 ohms
(GR7/GR7J)
SURROUND SPEAKER
(US and Canadian models):
accepts impedance of 16 ohms.
SUPER WOOFER (GR7/GR7J/
RX70 : US and Canadian models):
Voltage 1 V, impedance 1 kilo ohm
Photo: HCD-RX70