17
R -320FK
R-320FQ
R-320FW
TEST PROCEDURES
PROCEDURE
LETTER
COMPONENT TEST
clearing with a beep the key unit is faulty and must be replaced. If the control unit does not respond,
it is faulty and must be replaced. If a specific pad does not respond, the above method may be used
(after clearing the control unit) to determine if the control unit or key pad is at fault.
5. Reconnect all leads removed from components during testing.
6. Re-install the outer case (cabinet).
7. Reconnect the power supply cord after the outer case is installed.
8. Run the oven and check all functions.
1. Disconnect the power supply cord, and then remove outer case.
2. Open the door and block it open.
3. Discharge high voltage capacitor.
4. Disconnect the leads to the primary of the power transformer.
5. Ensure that these leads remain isolated from other components and oven chassis by using insulation
tape.
6. After that procedure, re-connect the power supply cord.
7. Remove the outer case and check voltage between Pin No. 1 of the 2 pin connector (A) and the normal
open terminal of the relay RY1 on the control unit with an A.C. voltmeter.
The meter should indicate 120 volts, if not check oven circuit.
RY1 and RY2 Relay Test
These relays are operated by D.C. voltage
Check voltage at the relay coil with a D.C. voltmeter during the microwave cooking operation.
DC. voltage indicated .............. Defective relay.
DC. voltage not indicated ........ Check diode which is connected to the relay coil. If diode is good,
control unit is defective.
RELAY SYMBOL
OPERATIONAL VOLTAGE
CONNECTED COMPONENTS
RY1
Approx. 24.0V D.C.
Oven lamp / Turntable motor / Cooling fan motor
RY2
Approx. 24.0V D.C.
Power transformer
8. Disconnect the power supply cord, and then remove outer case.
9. Open the door and block it open.
10. Discharge high voltage capacitor.
11. Reconnect all leads removed from components during testing.
12. Re-install the outer case (cabinet).
13. Reconnect the power supply cord after the outer case is installed.
14. Run the oven and check all functions.
K
RELAY TEST
4
3
8
7
2
1
9
5
6
0
START
BEVERAGE
KEEP WARM
PLUS
POWER
LEVEL
CHICKEN
BREAST
BONE-IN
POULTRY
BONELESS
POULTRY
MINUTE
PLUS
HOT
WATER
SENSOR
REHEAT
CUSTOM
HELP
STEAKS
CHOPS
BAKED
POTATOES
FISH
SEAFOOD
POPCORN
RICE
STOP
CLEAR
TIMER
CLOCK
FROZEN
VEGETABLES
FRESH
VEGETABLES
FROZEN
ENTREES
GROUND
MEAT
FRESH
ROLLS/
MUFFINS
FROZEN
ROLLS/
MUFFINS
GROUND MEAT
( DEFROST CENTER)
G 8
G 9
G10
G11
G12
G13
G14
G 7
G 6
G 5
G 4
G 3
G 2
G 1
