10
R-1512
R-1511
N
RELAY TEST
O
DEFROST CENTER TEST
TEST PROCEDURES
PROCEDURE
LETTER
COMPONENT TEST
1. Disconnect the power supply cord, and then remove outer case. Refer to procedure of “ HOOD
EXHAUST LOUVER REMOVAL ”, “ REMOVAL OF OVEN FROM WALL ” and “ OUTER CASE
REMOVAL ”.
2. Open the door and block it open.
3. To discharge high voltage capacitor, wait for 60 seconds.
4. Remove the hood intake duct R.
5. Disconnect the leads to the primary of the power transformer.
6. Ensure that these leads remain isolated from other components and oven chassis by using insulation
tape.
7. After that procedure, re-connect the power supply cord.
8. Check voltage between normal open terminal of the relay RY2 and the normal open terminal of the
relay RY1 on the control unit with an A.C. voltmeter.
The meter should indicate 120 volts, if not check oven circuit.
RY1, RY2, RY3, RY4, RY5 and RY6 Relay Test
These relays are operated by D.C. voltage
Check voltage at the relay coil with a D.C. voltmeter during the microwave cooking operation.
DC. voltage indicated ..................... Defective relay.
DC. voltage not indicated ............... Check diode which is connected to the relay coil. If diode is
good, control unit is defective.
RELAY SYMBOL
OPERATIONAL VOLTAGE
CONNECTED COMPONENTS
RY1
Approx. 25.0V D.C.
Oven lamp / Fan motor / Turntable motor
RY2(COOK)
Approx. 24.5V D.C.
Power transformer
RY3
Approx. 25.0V D.C.
Hood motor
RY4
Approx. 25.0V D.C.
Hood motor
RY5
Approx. 25.0V D.C.
Hood lamp
RY6
Approx. 25.0V D.C.
Hood lamp
9. Disconnect the power supply cord.
10. Open the door and block it open.
11. To discharge high voltage capacitor, wait for 60 seconds.
12. Reconnect all leads removed from components during testing.
13. Re-install the hood intake duct R.
14. Re-install the outer case (cabinet).
15. Reconnect the power supply cord after the outer case is installed.
G11
G12
G 9
G 8
POPCORN
BEVERAGE
REHEAT
FRESH
VEGETABLES
POWER
LEVEL
BAKED
POTATOES
DEFROST
CENTER
CUSTOM
HELP
TIMER
CLOCK
HOT
WATER
LIGHT
HI / LO
FAN
HI / LO
1
2
4
5
3
8
6
9
0
7
KEEP
WARM
PLUS
FRESH
ROLLS /
MUFFINS
SENSOR
COOK
CENTER
FROZEN
ROLLS /
MUFFINS
G 7
G 6
G 5
G 4
G 3
G 2
G 1
G10
STOP
CLEAR
START
MINUTE
PLUS
(1) Open the door.
(2) Place one cup of water in the center of the turntable tray in the oven cavity.
(3) Touch the “ DEFROST CENTER ” pad once. And then touch the number pad “ 2 ”.
(4) Touch the number pad “ 5 ”.
(5) Close the door.
(6) Touch the “ START ” button.
(7) The oven is in Defrost center cooking condition.
