Napoleon BGD40-P Installation And Operating Instructions Manual Download Page 7

Page: 7 / 104

W415-0811 / D / 08.16.12

2.3 GENERAL INFORMATION

When the appliance is installed at elevations above 4,500 ft, and in the

absence of speci



c recommendations from the local authority having

jurisdiction, the certi



ed high altitude input rating shall be reduced at the

rate of 4% for each additional 1,000 ft.
This appliance is approved for bathroom, bedroom and bed-sitting room

installations and is suitable for mobile home installation.
No external electricity (110 volts or 24 volts) is required for the gas system

operation. Expansion / contraction noises during heating up and cooling

down cycles are normal and are to be expected.
If utilizing one of Wolf Steel's trim or surround kits, follow the framing instructions and the



nishing instructions,

for removal of the top extension.

NOTE: The protective wrap on plated parts is best removed when the assembly is at room temperature

but this can be improved if the assembly is warmed, using a hair dryer or similar heat source.

66.8%

BGD40

2.4 RATING PLATE INFORMATION

SERIAL NUMBER/
NO. DE SERIE:

BGD40

W385-0656

CERTIFIED UNDER / HOMOLOGUE SELON LES NORMES: ANSI Z21.50b-2009 CSA 2.22b-2009 VENTED GAS FIREPLACE / FOYER AU GAZ AVEC EVACUATION

NOT FOR USE WITH SOLID FUEL. FOR USE WITH
COVERS AND GLASS DOOR CERTIFIED WITH THIS
UNIT ONLY.

WARNING:

DO NOT ADD ANY MATERIAL TO THE APPLIANCE, WHICH WILL COME IN

CONTACT WITH THE FLAMES, OTHER THAN THAT SUPPLIED BY THE MANUFACTURER WITH
THE APPLIANCE.
MINIMUM CLEARANCE TO COMBUSTIBLE MATERIALS /
DEGAGEMENTS MINIMAUX DES MATERIAUX COMBUSTIBLES:
TOP, FLOOR, SIDES & BACK

0”

DESSUS, PLANCHER, COTES ET ARRIERE
RECESSED DEPTH (CORNER INSTALLATION ONLY)

25 1/4”

PROFONDEUR D’ENCASTRE (INSTALLATION DU COIN SEULEMENT)
VENT / EVENT

1”

MANTEL HEIGHT / HAUTEUR DU MANTEAU

5”*

MAXIMUM HORIZONTAL EXTENSION/L’EXTENSION HORIZONTALE MAXIMALE: 3”.  SEE
INSTRUCTION MANUAL FOR GREATER EXTENSIONS.  REFERER AU MANUEL
D’INSTRUCTION POUR DES EXTENSIONS PLUS GRANDES.
MINIMUM AND MAXIMUM HORIZONTAL VENT LENGTHS ARE 10 INCHES AND 20 FEET
RESPECTIVELY.  LES LONGUEURS HORIZONTALES MINIMALE ET MAXIMALE SONT 10
POUCES ET 20 PIEDS RESPECTIVEMENT.

WOLF STEEL LTD.

24 NAPOLEON ROAD, BARRIE, ON, L4M 0G8 CANADA

UN COMBUSTIBLE SOLIDE NE DOIT PAS ETRE UTILISE

AVEC CET APPAREIL. UTILISER AVEC LES

COUVERTURES ET LES PORTES VITREES

HOMOLOGUEES SEULEMENT AVEC CETTE UNITE.

AVERTISSEMENT:

N’AJOUTEZ PAS A CET APPAREIL AUCUN MATERIAU DEVANT

ENTRER EN CONTACT AVEC LES FLAMMES AUTRE QUE CELUI QUI EST FOURNI AVEC CET
APPAREIL PAR LE FABRICANT.

THE APPLIANCE MUST BE VENTED USING THE APPROPRIATE WOLF STEEL VENT KITS. SEE
OWNERS INSTALLATION MANUAL FOR VENTING SPECIFICS. PROPER REINSTALLATION AND
RESEALING IS NECESSARY AFTER SERVICING THE VENT-AIR INTAKE SYSTEM.

L’APPAREIL DOIT EVACUER SES GAZ EN UTILISANT L’ENSEMBLE D’EVACUATION PROPRE A
WOLF STEEL. REFERER AU MANUEL D’INSTALLATION DE PROPRIETAIRE POUR
L’EVACUATION PRECISE. IL EST IMPORTANT DE BIEN REINSTALLER L’EVENT APRES AVOIR
ASSURE LE MAINTIEN DU SYSTME DE PRISE D’AIR.

ELECTRICAL RATING / CLASSIFICATION: 115V, 0.82 AMP, 60HZ
OPTIONAL FAN KIT / ENSEMBLE DE VENTILATEUR FACULTATIF: GZ-550KT

9700539 (WSL)

4001657 (NGZ)

4001658 (NAC)

4001659 (WUSA)

FOYER A GAZ VENTILE DIRECT. HOMOLOGUE POUR INSTALLATION DANS UNE CHAMBRE A

COUCHER,  USE  SALLE  DE  BAIN  ET  UN  STUDIO.   APPROPRIE  POUR  INSTALLATION
DANS UNE MAISON MOBILE SI SON INSTALLATION CONFROME AUX EXIGENCES DE LA
NORME  CAN/CSA  Z240MH  SERIE  DE  MAISONS  MOBILES  EQUIPEES  AU  GAZ,  EN
VIGUEUR  AU  CANADA  OU  AUX  ETATS-UNIS  DE  LA  NORME  DE  SECURITE  ET  DE
CONSTRUCTION  DE  MAISONS  MANUFACTUREES,  TITRE  24  CFR,  SECTION  3280.
DANS  LE  CAS  OU  CETTE  NORME  D’ETATS-UNIS  NE  PEUT  ETRE  APPLIQUEE,  SE
REFERER A LA NORME RELATIVE AU CRITERE DE MESURES DE SECURITE CONTRE
L’INCENDIE  POUR  LES  INSTALLATION  DANS  LES  MAISONS  MANUFACTURES,  LES

SITES ET LES COMMUNAUTES, ANSI/NFPA 501A.

DIRECT VENT GAS FIREPLACE.  APPROVED FOR BEDROOM, BATHROOM AND BED-SITTING
ROOM INSTALLATION.  SUITABLE FOR MOBILE HOME INSTALLATION IF INSTALLED IN
ACCORDANCE  WITH  THE  CURRENT  STANDARD  CAN/CSA  Z240MH  SERIES  GAS
EQUIPPED  MOBILE  HOMES,  IN  CANADA  OR  IN  THE  UNITED  STATES  THE
MANUFACTURED  HOME  CONSTRUCTION  AND  SAFETY  STANDARD,  TITLE  24  CFR,
PART 3280.  WHEN THIS US STANDARD IS NOT APPLICABLE USE THE STANDARD FOR
FIRE  SAFETY  CRITERIA  FOR  MANUFACTURED  HOME  INSTALLATIONS,  SITES  AND
COMMUNITIES, ANSI / NFPA501A.

BGD40G- N

BGD40-N

BCDV400-N

MODEL

BGD40-P

BCDV400-P

BGD40G-P

0-4500FT (0-1370m)

ALTITUDE / ELEVATION

0-4500FT (0-1370m)

30,000 BTU/h

INPUT / ALIMENTATION

30,000 BTU/h

20,000 BTU/h REDUCED INPUT / ALIMENTATION REDUITE

20,000 BTU/h

MANIFOLD PRESSURE:

3.5" WATER COLUMN

MANIFOLD PRESSURE:

10" WATER COLUMN

PRESSION AU COLLECTEUR:

3.5" D'UNE COLONNE D'EAU

PRESSION AU COLLECTEUR:

10" D'UNE COLONNE D'EAU

MINIMUM SUPPLY PRESSURE:

4.5" WATER COLUMN

MINIMUM SUPPLY PRESSURE:

11" WATER COLUMN

PRESSION D'ALIMENTATION MINIMALE:

4.5" D'UNE COLONNE D'EAU

PRESSION D'ALIMENTATION MINIMALE:

11" D'UNE COLONNE D'EAU

MAXIMUM SUPPLY PRESSURE:

7.0" WATER COLUMN

MAXIMUM SUPPLY PRESSURE:

13" WATER COLUMN

PRESSION D'ALIMENTATION MAXIMALE:

7.0" D'UNE COLONNE D'EAU

PRESSION D'ALIMENTATION MAXIMALE:

13" D'UNE COLONNE D'EAU

For rating plate location, see “INSTALLATION OVERVIEW” section.
This illustration is for reference only. Refer to the rating plate on the appliance for accurate information.

NOTE: The rating plate must remain with the appliance at all times. It must not be removed.

Altitude (FT)

0-4,500

0-4500

Max. Input (BTU/HR)

30,000

Max. Output Steady State (BTU/HR)

20,400

Min. Inlet Gas Supply Pressure

4.5" Water Column

11" Water Column

Max. Inlet Gas Supply Pressure