Morgan PLUS FOUR, Owner'S Handbook Manual

Page: 52 / 74

49
Brakes
WARNING The importance of brake maintenance cannot be over-stressed.
The owner is legally required to keep the braking system to a satisfactory
performance level. Brake pads and linings must be renewed in axle sets.
Failure to do so will seriously affect the operation of the system.
WARNING Any drop in reservoir fluid level or operation standards must
be reported immediately to a dealer.
WARNING Never make modifications to the braking system.
Trained personnel must carry out changes. It is recommended that a
qualified engineer or Morgan service agent should carry out all repairs and
brake services.
WARNING Care must be taken when handling brake fluid, as it may cause
skin problems. Follow manufacturers instructions carefully.
WARNING Use only new brake fluid.
WARNING Never leave fluid exposed to the air, as it will absorb moisture.
WARNING Brake fluid will damage paint and other finished surfaces.
WARNING Use only the recommended brake fluid or equivalents.
WARNING This car is fitted with servo-assisted brakes. DO NOT move
the car without the engine running, as the effort required will be greatly
increased. The car will stop if the pedal is pressed hard enough.
Brake Fluid Reservoir
The brake fluid reservoir is situated under the right hand bonnet on RHD
vehicles and under the left hand bonnet on LHD vehicles.
Every 5,000 miles (8,000km) remove the cover and check fluid level in the
reservoir. There is a minimum and maximum level mark on the rear of the
reservoir, the fluid should be filled to the maximum mark. If necessary replenish
using a funnel and flexible hose to within ½” (12mm) of the top with DOT
4 Brake Fluid. Replace cover ensuring that the rubber-sealing ring is in good
condition and that the ventilation hole is unblocked. If significant topping-up is
required check the master cylinder, slave cylinders and pipes for leakage, any
leakage must be rectified immediately.
The brake fluid in the system must be drained and replaced every 2 years.
The brakes will be inspected regularly during a normal service. Cleanliness
is essential when dealing with brakes as grease or oil cannot be removed
from brake linings. Always replace brake parts with genuine Morgan original
specification components.
WARNING Brake fluid is hazardous and will cause illness or even death
if swallowed.
WARNING Use only the specified brake fluid; using the incorrect fluid
may cause damage to the brake system.
WARNING Using incorrect brake components or excessively worn
components will affect your braking system and may result in an accident
causing serious injury or even death.