Mega MMP4, Maintenance Manual

Page: 40 / 96

9-1
MMP4-CAT(T4)-MX-2
26 Feb 2014
SECTION 9
Special Inspections
Contents
DESCRIPTION
This section contains special inspection requirements
for a specific system after use, an unusual event or
storage.
STORAGE/WINTERIZATION
ENTERING
1. Remove any exterior dirt, grease and grime that
may trap moisture.
2. Flush all water suction and discharge tubes (e.g.
water pump,).
3. Ensure all water is drained from the tubes and
water pump.
4. Ensure all covers/caps for fluid reservoirs are in
proper operating condition and are secured to
the openings.
5. Fill Fuel tank to capacity, close fuel shut off valves
at bottom of fuel tank.
6. Check tires for proper inflation.
7. Check Boom retaining hardware, ensure it is
operational and secure.
8. Lubricate all grease points (e.g. Hinge pins,
cylinder pins, water pump suction bowl).
9. Check battery fluid level and charge.
10. Disconnect battery cables from battery.
11. Service all engine systems per CAT C2.2T Diesel
engine service manual (SEBU8312-02).
12. If possible, shelter entire unit from the elements.
REMOVING
1. Remove all covers and seals from all fill/discharge
openings and components.
2. Inspect piping for debris that may damage unit
that water will be pumped into.
3. Check to ensure all water pump reservoirs are
filled to the correct level and the fluid is not
contaminated.
4. Remove any exterior dirt, grease and grime and
treat any corrosion.
5. Service all Engine systems per CAT C2.2T Diesel
engine service manual (SEBU8312-02).
6. Check all fluid levels for condition and level,
replace or adjust as necessary.
7. Check Braking system (if equipped) repair as
necessary.
8. Check safety chains for damage.
9. Check lighting system for proper operation,
repair as necessary.
10. Clean and connect battery cables to battery.
11. Perform all ‘Daily’ maintenance checks, repair as
necessary.
12. Perform a full functional check of all MMP4
control systems.
Description .........................................................................9-1 Storage/Winterization....................................................9-1