43
metal tools to short between the battery terminals and metal mower parts. Always keep protective battery
covers in place.
WARNING:
Incorrect battery cable routing could cause damage to the mower and battery cables. This
can cause sparks which can cause a battery short circuit which could result in serious personal injury.
WARNING:
Always disconnect battery cables by turning the battery disconnect switch to OFF position
when transporting unit.
Battery Connectors
Always disconnect battery cables by turning the battery disconnect switch to OFF position before
performing maintenance on the unit.
Battery Maintenance
Your Mean Green Mower is powered by 1 Lithium Module (LEM) which, when maintained properly, will
provide years of useful life.
For proper care, adhere to the instructions on page 47.
WARNING:
Charge only with a Mean Green Mower approved charger. Do not use battery chargers
other than those recommended by Mean Green Products. Incorrect battery charging will void warranty and
can lead to equipment damage, fire, serious injury or death.
1.
Always charge batteries after each use, regardless of how little used. Once charging is complete, charger
can be disconnected. Charger may not turn back on once charging is complete. NOTE: Unplug charger from
outlet and then from mower charging port!
2.
Check that battery cables are securely tightened to batteries each time you service the battery.
3.
Keep grass, dirt and debris from collecting near battery terminals.
4.
Batteries are not to remain in a discharged state or damage to the batteries will occur. Immediately
charge at least 15 minutes after a complete discharge of battery pack.
5.
Charge batteries indoors in a well-ventilated and dry location away from sparks or flames. Never expose
charger to rain, vapor or liquid (dry location use only).
6. Charge only
Lithium Modules (LEMs) provided with the Mean Green Mower.
7.
Do not touch un-insulated portion of charger (terminal pins) of output connector. (if applicable on model)
8.
Do not use with defective cords and wires. Replace defective cords and wires immediately.
Battery Charging Procedures and Options
WARNING: Batteries should not be removed from unit unless repair is needed. Use EXTREME
Caution When Lifting Batteries Out of Mower Unit. Serious Injury to operator and/or Battery Could Occur
If Battery Is Mishandled or Dropped!!
WARNING: Do Not Use An Extension Cord To Charge Mower!
If an extension cord must be used, it
must have a minimum of 10 AWG wires and be of the shortest length possible (10-25 ft long). Never leave
any cords coiled as excessive heat can build up and melt insulation of extension cord wires!
Chargers include: LEMC3548 (Standard Charger)
See separate guidelines for each below!
The charger will charge from a Standard 220-240V outlet at 35 amps-48volts. This will be drawing around
13 amps from the wall outlet. NOTE: It is recommended to have a dedicated circuit for charging!!
DO NOT USE extension cords with chargers (see above note)!!
Pictured below notice the charger has a fan on the top of unit for cooling and 2 cords
–
1 from the left side
and 1 from the right side. The cord with the RED Anderson Connector plugs into the charging port of the
mower and the second cord plugs into the electrical wall outlet. The charger also has a light on the front of
the unit
–
RED indicates charging and GREEN indicates battery is charged.
Summary of Contents for MGRVL60S220
Page 17: ...16 Battery Screen Setting Screen Setup Admin Passcode...
Page 40: ...39 Fig 20A Fig 20C Fig 20B...
Page 42: ...41 Fig 20G Fig 20F...
