Malibu Boats Wakesetter 247 LSV, Owner'S Manual

Page: 142 / 170

Engine Specifications
Notes
1) Minimum recorded compression in any one cylinder should not be less than 70% of the highest recorded cylinder.
2) Measured using an accurate shop tachometer at normal operating temperature. Idle RPM on EFI models is not adjustable.
3) Timing must be set using special procedures indicated in the appropriate service manual. Timing cannot be set using
conventional methods. Special tool(s) required.
4) Always use dipstick to determine exact quantity of oil required. Do not fill above “FULL” mark.
5) Do not over fill. Correct level is at the “Full Cold” mark on the coolant recovery bottle when coolant is cold.
Engine Models 5.7L MPI (335/350 Monsoon) LSA L96
Number of Cylinders V-8
Displacement 350 CID (5.7L) 376 CID (6.2L) 364 CID (6.0L)
2011 Malibu Engines
Fluid Capacities
Crankcase (with Filter)
4
5.5 Quarts (5.25L) 6 Quarts (5.7L)
ZF Ski Vee Transmission 4 2.12 Quarts (2L) Main Gearbox, 1.0 Quart (1.06L) V-drive - Dexron 3
ZF V-Drive Transmission
4
4.2 Quarts (4L) Pennzoil 15W40
Walter V-Drive 0.5 Quart (0.5L) Pennzoil SAE 30 Motor Oil
In-Line 1:1 Transmission 4 1.7 Quarts (1.6L) Dexron 3 ATF
In-Line Reduction Gear 4 2.12 Quarts (2L) Pennzoil 15W40
Closed Cooling System
5
12-14 Quarts (11.4-13.3L)
Spark Plug Gap .040 in. (1.02 mm)
Base Timing at 1000 RPM 3 Nonadjustable
Thermostat 160°F (71°C)
Firing Order 1-8-4-3-6-5-7-2 1-8-7-2-6-5-4-3
Spark Plug Type AC 41-101 AC 41-110
Electrical System 12 Volt DC Negative (-) Ground
Min. Battery Requirements 650 cca/700 mca/120 Ah
Operating Range at WOT 4600-5200 RPM 5200-5600 RPM
Oil Pressure at Idle 4 PSI (41 kPa) Minimum Hot
Oil Pressure at 2000 RPM 18 PSI (124 kPa) Minimum Hot
Idle RPM in Neutral 2 650 ± 50 RPM
Compression Ratio 9.4:1 10.7:1/9.1:1 9.6:1
Compression Pressure 1 Minimum 100 PSI (690 kPa)
4.0012 x 3.480 in. 4.065 x 3.622 in. 4 x 3.622 in.
(101.63 x 88.39 mm) (103.25 x 92 mm) (101.6 x 92 mm)
Oil Filter Pennzoil PZ52, AC-PF25
Bore/Stroke
Fuel Pump Pressure 60 PSI Minimum at Keyup (414 kPa)
4-6
Chapter 4_11_ Chapter 4 doc.qxd 11/19/10 12:33 PM Page 6