Malaguti SPIDER MAX RS 500, Service Manual

Page: 16 / 81

15 02/08
Max
Min
TRANSMISSION OIL
CHECK THE LEVEL
1) Place the vehicle on a level surface on its centre stand.
2) Unscrew the dipstick (A), clean it and refit it, wrenching it tightly.
3) Pull it out again and check that the oil level is between the MIN and MAX notches.
4) If the level is insufficient, top up until you almost reach the MAX notch.
5) Fill the crankcase with this type of oil: Q8 ZC 90
Crankcase capacity approx.: 250 cm3
RENEW
• Carry out the operations described above at points 1-2, without refitting the dipstick; then put a container under the
engine crankcase and unscrew the drainage screw (B), paying attention to the gasket.
• Let oil flow into the container (pay attention to avoid scorching).
• Refit the drain plug with gasket and fill with approximately 250 cm3 of new oil (Q8 ZC 90), then refit the cap and
dipstick (A).
• Now repeat checks 3-4-5. If the drainage screw gasket is damaged, replace it.
Regularly check for oil leakages near the drain plug at the rear wheel.
every 6000 km or 12 months
after the first 1,000 km and every 24,000 km
F. 10
F. 11
A
B