262150
51
Revision A
4.1.1
Shortening the Power Take-Off Driveline
It may be necessary to shorten the power take-off (PTO) driveline so that it does not bottom out when the three-point
linkage is fully raised and to ensure that there is enough room to remove the driveline
’
s quick disconnect from the tractor
PTO shaft.
1.
Ensure the float module is set to operating height and angle (10 degrees forward and 400 mm [15 3/4 in.] above the
ground).
1035069
A
B
Figure 4.9: Driveline Halves
2.
Separate driveline halves (A) and (B).
1034430
A
B
Figure 4.10: Tractor PTO
3.
Clean and grease the tractor PTO and implement shaft
before installing the driveline.
4.
Pull back collar (B) on the driveline half, and slide the
driveline onto tractor
’
s PTO shaft (A) until it locks in place.
Release the collar and ensure the yoke is locked onto
the shaft.
5.
Fully raise the tractor
’
s three-point linkage.
1035064
L
A
Figure 4.11: PTO Driveline Halves
6.
Align the two drivelines halves so they are parallel to each
other. Check that PTO half (A) is short enough that it will
not bottom out when the three-point linkage is fully raised,
and there is enough room to remove the driveline
’
s quick-
disconnect from the tractor PTO shaft.
IMPORTANT:
Ensure you cut only as much as necessary to meet the
above conditions. Telescoping tubes must always overlap
by at least 1/2 of their length in normal operation and at
least 1/3 of their length in all working conditions in order to
keep the tubes aligned and allow them to slide freely.
7.
If driveline half (A) needs to be shortened, measure the
length (L) that needs to be removed.
Summary of Contents for TM100
