Land Pride SBD35108, Operator'S Manual

Page: 3 / 48

Table of Contents
4/9/21
©
Copyright 2021 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use
of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this
product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
SBD3596 & SBD35108 Snow Blowers 370-347M
ii
Table of Contents
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look for the Safety Alert Symbol . . . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . 10
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 10
Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Section 1: Assembly & Set-up . . . . . . . . . . . 11
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 11
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 11
Uncrating the Snow Blower . . . . . . . . . . . . . . . . . . 11
Chute Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Deflector, Manual Adjustment (Standard) . . . . . . . 12
Deflector, Hydraulic Adjustment (Optional) . . . . . . 13
Chute Rotation, Hydraulic Motor . . . . . . . . . . . . . . 13
Convert 540 rpm to 1000 rpm Drive . . . . . . . . . . . 14
Remove 540 rpm Components . . . . . . . . . . . . . 14
Install 1000 rpm Components . . . . . . . . . . . . . . 14
Install 1000 rpm Horizontal Guard . . . . . . . . . . . 15
Section 2: Tractor Hook-up & Unhook . . . . . 16
Driveline Maximum Allowable Length . . . . . . . . . . 16
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 16
Hitch Pin Set-up . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Standard 3-Point Hook-up . . . . . . . . . . . . . . . . . 17
Special 3-Point Hook-up . . . . . . . . . . . . . . . . . . 17
Standard Quick Hitch Hook-up . . . . . . . . . . . . . . 17
Tractor Hook-up . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Leveling The Snow Blower . . . . . . . . . . . . . . . . . . 19
Driveline Hook-up . . . . . . . . . . . . . . . . . . . . . . . . . 19
Hydraulic Hook-up . . . . . . . . . . . . . . . . . . . . . . . . 19
Hydraulic Motor (Chute Rotate) . . . . . . . . . . . . . 19
Hydraulic Cylinder
(Deflector Adjustment Option) . . . . . . . . . . . . . . 19
Check Driveline Interference . . . . . . . . . . . . . . . 20
Unhook Snow Blower . . . . . . . . . . . . . . . . . . . . . . 21
Section 3: Adjustments . . . . . . . . . . . . . . . . . 22
Park Stand . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Adjust Stand to Unhook . . . . . . . . . . . . . . . . . . . 22
Adjust Stand After Hook-up . . . . . . . . . . . . . . . . 22
Deflector Adjustment . . . . . . . . . . . . . . . . . . . . . . . 22
Manual Adjustment (Standard) . . . . . . . . . . . . . . 22
Hydraulic Cylinder Adjustment (Optional) . . . . . . 22
Chute Rotation Gear Alignment . . . . . . . . . . . . . . . 23
Chute Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Outer Skid Shoe (Optional) . . . . . . . . . . . . . . . . . . 24
Inner Skid Shoe (Optional) . . . . . . . . . . . . . . . . . . 24
Hitch Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Roller Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Section 4: Operating Instructions . . . . . . . . . 26
Operating Checklist . . . . . . . . . . . . . . . . . . . . . . . . 26
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 26
Inspection Procedures . . . . . . . . . . . . . . . . . . . . . . 28
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Tractor Shutdown Procedure . . . . . . . . . . . . . . . . . 28
General Operator Instructions . . . . . . . . . . . . . . . . 29
Section 5: Maintenance & Lubrication . . . . . 31
General Maintenance Information . . . . . . . . . . . . . 31
Auger & Impeller Inspection . . . . . . . . . . . . . . . . . 31
Shearbolt Protection . . . . . . . . . . . . . . . . . . . . . . . 32
Replace Driveline Shearbolt . . . . . . . . . . . . . . . . 32
Replace Drive Shaft Shearbolt . . . . . . . . . . . . . . 32
Drive Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Outer Skid Shoes (Optional) . . . . . . . . . . . . . . . . . 33
Inner Skid Shoes (Optional) . . . . . . . . . . . . . . . . . 34
Grader Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Hydraulic System . . . . . . . . . . . . . . . . . . . . . . . . . 35
Long Term Storage . . . . . . . . . . . . . . . . . . . . . . . . 35
Order Replacement Parts . . . . . . . . . . . . . . . . . . . 35
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Shearbolt Sprocket Hub . . . . . . . . . . . . . . . . . . . 36
Auger Flange Bearings . . . . . . . . . . . . . . . . . . . . 36
Drive Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Driveline U
- joints . . . . . . . . . . . . . . . . . . . . . . . . 37
Driveline Shear Bolt . . . . . . . . . . . . . . . . . . . . . . 37
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Section 6: Specifications & Capacities . . . . . 38
Section 7: Features & Benefits . . . . . . . . . . . 40
Section 8: Troubleshooting . . . . . . . . . . . . . . 41
Section 9: Torque Values Chart . . . . . . . . . . . 42
Section 10: Warranty . . . . . . . . . . . . . . . . . . . 43