Kubota ZG222A, Operator'S Manual

Page: 82 / 111

PERIODIC SERVICE 62
ENGLISH
B Checking Carbon Canister Air Filter
If you feel you are unable to make the following service
correctly and safely, contact your local KUBOTA Dealer.
Check the carbon canister air filter every 100 hours of
operation. (more often under extremely dusty or dirty
conditions.)
To avoid personal injury:
A
Always stop the engine, set the parking brake,
remove the key, and disengage PTO.
1. Open the air intake screen.
2. Remove the cover and remove the carbon canister air
filter.
3. Check to see if the carbon canister air filter is worn out,
damaged or dirty.
4. If the air filter is dirty, wash the air filter in warm water
with detergent. Then rinse the air filter thoroughly until
all traces of detergent are eliminated. Squeeze out
excess water. (do not wring.) Allow the air filter to air
dry. Do not use high pressure air to clean filter.
5. If the air filter is worn out, damaged or too dirty to wash
clean, replace it with a new one.
6. Reinstall the carbon canister air filter and secure it with
the cover.
A
Operating in dusty condition may require more
frequent maintenance than above.
EVERY 150 HOURS
B
Changing Gear Box Oil
To avoid personal injury:
A
Be sure to stop the engine and remove the key
before changing the oil.
1. To drain the used oil, remove the oil inlet plug at the
gear box, tilt the mower deck and drain the oil
completely into the oil pan.
2. Fill with the new oil up to the check plug port.
(See "LUBRICANTS AND FUEL" in "MAINTENANCE"
section.)
3. After filling reinstall the oil inlet plug and the check
plug.
(1) Canister air filter
(2) Cover
(3) Carbon canister (A) Air intake screen
(B) Air port
If serial numbers of mower are as indicated below
RCK48S-222Z:all
(1) Check plug
(2) Oil inlet plug