![background image](http://html1.mh-extra.com/html/jayco/jay-flight-bungalow-2009/jay-flight-bungalow-2009_owners-manual_3624375091.webp)
SECTION 11
STORAGE & MAINTENANCE
87
_ Remove snow loads from the top of your
park trailer to prevent damage to the unit’s
structure.
M
AINTENANCE
C
HECKLIST
This list is a quick reference sheet for
suggested areas of regular maintenance.
Review all OEM operator’s manuals supplied
with your park trailer to perform these listed
maintenance items.
Prior to First Trip
_ Have propane lines checked for leaks.
_ Check wheel lug nuts at specified intervals
to listed torque specifications, re-torque as
needed (refer to the axle OEM operator’s
manual).
_ Open all windows and the entry door, start
the furnace. Leave the windows and door
open and the furnace ON until the odor
from the initial use of the furnace is fully
dissipated.
_ Sanitize fresh water system.
_
Test propane, smoke and carbon
monoxide detectors.
First Two-Hundred Miles
_ Check wheel nuts at specified intervals to
listed torque values. Re-torque as needed.
Refer to the axle manufacturer’s manual.
_ Have brakes adjusted by a qualified
service technician.
Each Trip
_ Check battery water level. (If equipped with
battery.)
_ Have propane lines checked for leaks.
_ Check running lights.
_ Check tire pressure and wear. Make sure
the tires are cold when checking the tire
pressure.
_ Flush out water heater tank.
_ Inspect safety chains for signs of wear. (if
applicable)
_ Test brakes.
_
Test propane, smoke and carbon
monoxide detectors.
After Every Tire Change
_ Tighten wheel nuts to specified torque
values at 10, 25 and 50 miles (16, 40, and
80 kilometers) to assure that they are
correctly “seated” after the tire change.
Refer to the axle OEM operator’s manual.
Daily
_ Ensure propane alarmr operation light is
green in color.
_ Recharge battery after each use.
Weekly
_ Have propane lines checked for leaks.
_ Check tire pressure and wear. Make sure
tires are cold when checking the tire
pressure.
_
Test propane, smoke and carbon
monoxide detectors.
Monthly
_ Check fire extinguisher pressure. Refer to
the fire extinguisher label for specific
instructions.
_ Clean and lubricate the coupler. (if
applicable)
_ Test the ground fault circuit interrupter
(GFCI)
Every Three Months or 3,000 Miles
_ Have propane lines checked for leaks.
_ Check wheel nuts at specified intervals to
listed torque values. Re-torque as needed.
Refer to the axle manufacturer’s manual.
_ Check, clean, tighten and lubricate battery
cables.
_ Compare refrigerator pilot flame with ideal
flame. Refer to the refrigerator OEM
operator’s manual for ideal flame. Have
cleaned and adjusted as necessary by a
qualified technician. (park trailer type
refrigerator only)
_ Compare water heater pilot flame with
ideal flame. Refer to the water heater OEM
operator’s manual for ideal flame. Have
cleaned and adjusted as necessary by a
qualified technician.
_ Drain and sanitize fresh water system.
_ Examine the tires for unusual wear,
sidewall defects from possible cuts,
bulging and abrasions.
_ Have brakes adjusted by a qualified
service technician.
_ Inspect propane cylinders for rust, pits,
gouges, scrapes or sharp dents. Repaint
cylinders if rust is present or replace if
needed.
Summary of Contents for Jay Flight Bungalow 2009
