Jayco 2008 Octane ZX, Owner'S Manual

Page: 94 / 104

qualified technician. (RV type refrigerator
only)
– Compare water heater pilot flame with ideal
flame. Refer to the water heater OEM
operator’s manual for ideal flame. Have
cleaned and adjusted as necessary by a
qualified technician.
– Drain and sanitize fresh water system.
– Examine the tires for unusual wear, sidewall
defects from possible cuts, bulging and
abrasions.
– Have brakes adjusted by a qualified service
technician.
– Inspect propane cylinders for rust, pits,
gouges, scrapes or sharp dents. Repaint
cylinders if rust is present.
– Inspect refrigerator combustion seals. Have
cleaned and adjusted as necessary by a
qualified
RV technician. (RV type
refrigerator only)
– Inspect refrigerator door seal.
– Lubricate hitch ball (if applicable)
– Lubricate tongue jack (if applicable)
Every Six Months or 6,000 Miles
– Check
pipe connections for tightness.
Tighten if necessary. Lubricate all moving
parts on the entrance steps.
– Clean and lubricate stabilizer jacks.
– Clean drains with approved drain cleaners.
– Have suspension system serviced by a
qualified service technician.
– Inspect and reseal as defined earlier in this
chapter.
– Inspect
wheels for cracks, dents or
distortion.
– Lubricate entrance and baggage door locks.
– Lubricate the bearing surface between the
rotating gear housing and the base plate on
the television antenna.
– Lubricate
the elevating gear on the
television antenna.
– Lubricate the rubber quad ring on the
elevating shaft located on the television
antenna.
– Perform routine preventative maintenance
on entire trailer and all component parts.
Every Year or 12,000 Miles
– Check demand tank vent for obstructions.
– Check
water pump connections and
mountings for tightness.
– Clean city water entry strainer.
– Have brakes inspected and serviced by a
qualified technician.
– Have furnace inspected and serviced by a
qualified technician.
– Have
propane system inspected and
serviced by a qualified technician.
– Have
the refrigerator inspected and
serviced by a qualified technician.
– Inspect and reseal as defined earlier in this
chapter.
– Lubricate moving parts on the awning
hardware. (Awning option only.)
– Manually operate the pressure-temperature
control lever on the water heater.
– Perform routine preventative maintenance
on entire trailer and all component parts.
– Repack wheel bearings.
– Replace battery on the carbon monoxide
detector.
– Rotate fluorescent tubes in the light fixtures.
Every Five Years
– Replace propane and carbon monoxide
detectors.
90
SECTION 11
STORAGE & MAINTENANCE